Abstract:This paper presented a pilot-scale investigation into the performance of stabilized-soil aggregates for subgrade, which was generated from dehydration and aggregation of excavated soft clay. The evaluation work consisted of three parts. Firstly, an industrialized production line, aiming to produce aggregates efficiently was established. The produced aggregates were then employed to construct a trial embankment. Finally, a series of in-situ tests were performed on the product and embankment to evaluate the suitability of the manufactured product for subgrade engineering. It was found that the technique proposed in the companion paper was also feasible on an industrial scale, and the dehydration rate was around 68 % of the laboratory scale, which was considerably higher than natural drying. Although the dehydration rate was decreased by a certain amount, enlarging the production scale from precisely controlled laboratory scale to field pilot scale had little effect on the engineering properties of products. After dehydration and aggregation, the high plasticity clayey soil was transformed into low plasticity silty soil, showing excellent soaked CBR values (over 30 %). When used within the embankment, the constructed embankment exhibited reliable stiffness (e.g., DCPI <= 4.2 mm/blow and Mr > 70 MPa) and premium water stability, which could well satisfy the requirement of extremely heavy traffic load stated in the standards. The influences of such modification of soil characteristics on estimation of in-situ CBR values and selection of compaction methods were also discussed. Based on the discussion, some recommendations for proper use of the stabilized-soil aggregates on subgrade engineering at an industrial scale were given.

Settling Behavior of Clay Suspensions Produced by Dredging Activities in China

Laboratory Study on Self-Weight Sedimentation and Consolidation Behaviors of Hydraulic-Dredged Mud

Dewatering-Induced Stratified Settlement Around Deep Excavation: Physical Model Study

Effect of Traffic Load on Permeability of Remolded Kaolin

Aggregation and Dehydration of Excavated Soft Clay and Use for Subgrade Engineering-Part 2: A Pilot-Scale Study

Centrifugal Model Test and Numerical Analysis of Deformation and Stability of Seawall on Soft Clay

Study on Mixing Cement-Waste By-Product to Stabilize Soft Marine Clay

Calculation On The Settlement Of Dredged Slurry Treated By Vacuum Preloading Method With Consideration Of Clogging Effects

Link Mining in Online Social Networks with Directed Negative Relationships

Stress–strain Response of Soft Clay to Traffic Loading

Simplified method for predicating consolidation settlement of soft ground improved by floating soil-cement column

Why Pile-Supported Building Settled Continuously after Water Level Was Stabilized During Dewatering: Clues from Interaction Between Pile and Multi Aquifers

Undrained Behaviour of Intact Soft Clay under Cyclic Paths That Match Vehicle Loading Conditions

The Effect of Initial Water Content on the Consolidation of Dredged Slurry under Vacuum Preloading

Experimental investigation on the treatment of different typical marine dredged sludges by flocculant and vacuum preloading

Consolidation Considering Increasing Soil Column Radius for Dredged Slurries Improved by Vacuum Preloading Method

Analysis of Settlement Reasons and Mechanism in Immersed Tunnel

Undrained deformation behavior of saturated soft clay under long-term cyclic loading

Model tests on compression of base layer of immersed tube tunnels considering siltation

Study on 1-D Nonlinear Consolidation Behavior for Ningbo Soft Clay with Threshold Gradient

Estimating Hydraulic Conductivity of Naturally Sedimented Clays Using Compression Curves