Abstract:The given paper is aimed at introducing our experimental study over the effect of the relief duct on the ventilation of the gas explosion in a spherical vessel. We have implemented the experiment by using a premixed methane-air mixture([φ(CH4) = 10%]without special instructions) to analyze the effects of the relief duct length,the vessel volume,the ignition position,the gas volume fraction and the membrane rupture pressure on the duct-venting explosion. The results of our experiment show that those parameters have significant effect on the process of the duct-vented explosion. In addition,both the positive pressure and negative pressure in the spherical vessel tend to increase with the increase of the length of the relief duct,whereas in the case of the closed explosion in the isolated spherical vessel,the vessel volume has hardly no effect on the peak pressure of gas explosion,for the gas explosion in the big vessel and the small vessel vented through the same relief duct(the duct length is 6 m and the diameter is 0. 06 m),though the peak pressure in the big vessel can be made as high as 3. 3 times as much as the peak pressure in the small vessel. Therefore,as compared with the closed explosion in the big isolated vessel,for the duct-vented explosion,the rate of pressure rise in the big vessel can be significantly higher because for the duct-vented explosion,compared to central ignition,the peak pressure in the vessel for rear ignition is higher; the relief duct results in that peak pressure in the vessel can be made much higher than that for the simply vented explosion(without relief duct). Therefore,considering the maximum reduced pressure,the duct-vented explosion,or simply the vented explosion,though the peak pressures in the vessel may increase with the increase of membrane rupture pressure,the difference can be gradually made smaller with the increase of the membrane rupture pressure,thus implying that the effect of the duct tends towards the mitigation. What is more,since the presence of the relief duct always tends to reduce the efficiency of the ventilation and increase the severity of the explosion,the effect of the presence of relief duct on venting process should be taken into full account and the compressive strength of the vessel itself should be improved even earlier than when they were at the moment the vessel was under design.

Effects of obstacles in duct on gas explosion in linked vessels

Effect of One Obstacle on Methane–air Explosion in Linked Vessels

Experimental Investigation And Numerical Simulation Of Gas Explosion In Linked Vessels

Experimental Investigation into Explosion of Premixed Gases in Linked Vessels

The Effect of an Obstacle on Methane-Air Explosions in a Spherical Vessel Connected to a Pipeline

The effects of built-in obstacles on methane-air explosion with concentration gradients: An experimental research

Effects of gas concentration and obstacle location on overpressure and flame propagation characteristics of hydrocarbon fuel-air explosion in a semi-confined pipe

Research on overpressure hazards and flame propagation behaviors of CH4/air mixture explosions in a vessel-duct connected device

Experimental Investigation of Gas Explosion in Single Vessel and Connected Vessels

Experimental Investigation of Gas Explosion Characteristic in Linked Vessels

Effects of an obstacle on the deflagration behavior of premixed liquefied petroleum gas-air mixtures in a closed duct

Influence of initial pressure on vented gas explosion in vessel with vent duct

The Experimental Study on Different Combinations of Connected Vessels in Airtight Explosion Process

Experimental Research On Gas Explosion Venting Of Premixed Gases In Linked Vessels

Experimental study over the effect of the relief duct on the venting of gas explosion in a spherical vessel

Effect of pipe length on methane explosion in interconnected vessels

The effect of concentration gradient on overpressure hazards and flame behavior of gas explosion in a vessel-duct connected device

The effect of flexible obstacles with different thicknesses on explosion propagation of premixed methane-air in a confined duct

Flame propagation by gas explosion in linked vessels with built-in obstacle

Gas Explosion Venting of Premixed Gases in Linked Vessels

Investigation on the characteristics of vented stoichiometric methane-air explosion: Effect of ignition positions and obstacles