Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

A Tentative Study on the Relationship Among External Pressure, Vapor Tension and Boiling Point

Measurement And Modeling Of The High-Pressure Phase Behavior Of The Carbon Dioxide Plus Propene Oxide Binary System

Measurement of Vapor Liquid Equilibrium for System of Ethyl Acetate-Pyridine at Different Pressures

Study and Applications of Binary and Ternary Azeotropes

The Experimental Study on Different Ratios of Vortex Tube Hot End Pressure and Cold End Pressure

THERMODYNAMIC CONSISTENCY FOR THE VAPOR-LIQUID EQUILIBRIUM DATA OF ASSOCIATING SYSTEM

Correlation of Vapor Liquid Equilibria from saturated vapor pressures for hydrocarbon systems

Vapor–Liquid Equilibrium for the Binary Systems 1,1,2,3,3,3-Hexafluoro-1-propene (R1216) + 2,3,3,3-Tetrafluoroprop-1-ene (r1234yf) and 1,1,2,3,3,3-Hexafluoro-1-propene (R1216) + Trans-1,3,3,3-tetrafluoropropene (R1234ze(e))

The p-V-T Relationship of Liquid Phase, Dew and Bubble Point Pressures and Densities of Binary Mixtures

A Relationship Between Flash Point and Boiling Point of the Flammable Liquids at Low Pressure

Droplet Evaporation to Boiling in Van Der Waals Fluid

Vapor–Liquid Equilibrium for the Mixture Methane (CH4) + Ethane (C2H6) over the Temperature Range (126.01 to 140.01) K

Bubble Point Pressure Measurement For Isothermal Quaternary System And Prediction Of Vapor-Liquid-Equilibrium

Measurement of bubble points, dew points and critical points of carbon dioxide/vinyl chloride binary system

Experimental Study of Liquid Fuel Boilover Behavior in Normal and Low Pressures

Studies on Phase Equilibria at Superatmospheric Pressures for Binary Systems of Chloroform,Ethanol and Benzene

Measurement of Bubble-Point Vapor Pressure for Systems of JP-10 with Ethanol

An Experiment Study on Flash Boiling Spray

Heat Transfer and Pressure Drop of Vapor-Liquid Solid Three-Phase Boiling Flow of Binary Mixtures

Measurements of Vapor Pressure and Vapor-Liquid Equilibria of Hydrocarbon Fuels

A Study of the Pressure Effect on the Relative Volatility of the Components in the Distillation Process of Mixtures of Different Natures