Abstract:Abstract Pressure pulsations induced by rotor-stator interaction (RSI) phenomenon are one of the major sources of excitation resulting in severe vibrations of pump-turbines and powerhouses. By now, many articles focus mainly on the RSI mechanism by methods of theoretical analysis, fluid-structure calculation and model test verification. There are few reports published on equipment and powerhouse vibrations induced by RSI. Therefore, in this paper we took a real RSI induced problem at Zhanghewan (ZHW) pumped storage power plant (PSPP). We employed frequency spectrum technology on signals of powerhouse vibrations and pressure pulsations in stable and transient processes, combined eigen-frequency measurement and numerical calculation of powerhouse localities, and then confirmed that partial powerhouse resonated with RSI induced pressure pulsation in the vaneless area (gap between guide vanes and runner blades). We statistically evaluated the relationship between the ratio of guide vane pitch diameter D 0 to the high-pressure runner diameter D 1 and vaneless area pressure pulsation from many PSPPs in China, and proposed solutions that new runner should use. The runner alteration work was successful. Model tests and field measurements show that vaneless pressure pulsation decreases and the powerhouse shows acceptable vibration levels. Many experiences were accumulated during this work, including that from an engineering perspective by enlarging the vaneless area it is possible to lower RSI induced pressure vibrations. Also, much attention should be paid on local anti-vibration calculations in the powerhouse designing period. Our research and review provide a new perspective for designing, refurbishing, rehabilitating of pump-turbines.

Low-frequency Vibration In High-pressure Turbines Rotor

A Simulation Study of Hydraulic Vibration caused by Clearance Flow in a Pump Turbine

Suppression of Low-frequency Vibration Fault

Pressure fluctuations in the vaneless space of High-head pump-turbines—A review

Vibration and noise of a high head pump turbine: analysis and improvement

Mechanical fault diagnosis for abnormal vibration excited by steam in high pressure turbine of turbo-generator set

Pump-turbine Rotor-Stator Interaction Induced Vibration: Problem Resolution and Experience

Numerical Investigation On The High-Cycle Pressure Fluctuation Mechanism Of Vnt Rotor

Mechanism analysis of the abnormal head-cover vibration of an ultra-high-head pump-turbine operating in pump mode by CFD and FEM

Dynamics of Slant Cracked Rotor for a Steam Turbine Generator System

Dynamic characteristics of the rotor system for large pump-turbine sets

Experimental Study on Large Turbine HP-Valve’s Excitation Fault Caused by Steam’s Unsteady Flow and Its Economic Solution

Numerical Investigations on Non-Synchronous Vibration and Frequency Lock-in of Low-Pressure Steam Turbine Last Stage

Vibration and fatigue caused by pressure pulsations originating in the vaneless space for a Kaplan turbine with high head

EXPERIMENTAL RESEARCH ON SOUND WAVES EXCITATION TO AERO-ENGINE COMPRESSOR ROTOR BLADE

Nonlinear Vibration Analysis of a Low-Pressure Rotor-Bearing System for 200MW Steam Turbine

Strong Pressure Fluctuations at the Rotation Frequency of Hydropower Units

Investigations on Pressure Fluctuations in the S-Shaped Region of a Pump–Turbine

Mechanism Analysis and Experimental Research on the Abnormal Turbine Shaft Vibration Caused by Power Control Mode Switching

Research on Vibration Fault Diagnosis Strategy for Commonly Supported Rotor of Turbogenerator

Dynamic Response Characteristics of Rotating and Fixed Components of the Kaplan Turbine under Low and Medium Heads