Abstract:In this paper, the Reynolds averaged Navier–Stokes equations coupled with the RNG k–ε turbulence model are employed to simulate the unsteady turbulent flow throughout the whole flow passage of a prototype Kaplan turbine. The behavior of the pressure fluctuation in the prototype Kaplan turbine, which includes the amplitude and frequency, is predicted and analyzed at several survey points in the turbine. Then, the mechanisms of generation and transmission of the main pressure fluctuation in the prototype turbine are discussed. After that, the frequency and amplitude of pressure fluctuation in the prototype turbine are compared with those of the model turbine. It is found that there is a similarity of pressure fluctuation between the prototype Kaplan turbine and the model turbine except at low frequency. At low frequency, the similarity of the pressure fluctuation fails due to the difference of the Reynolds number between the prototype turbine and the model turbine. It is observed from the simulation results that the pressure difference between the maximum and the minimum of pressure on each section of the draft tube can be utilized to estimate the relative pressure fluctuation in the draft tube for both the model and prototype turbines. It is also found in the frequency domain that there is a pressure fluctuation frequency at which the pressure suddenly rises in the draft tube. It is possible that this phenomenon is induced by the resonance nature of the water body system in the draft tube. At last, the comparison of pressure fluctuation at on-cam and non on-cam operation conditions of the prototype turbine is also carried out.

Detailed Simulation and Analysis of Pressure Fluctuation in Francis Turbine

Unsteady Turbulent Simulation of Prototype Hydraulic Turbine and Analysis of Pressure Fluctuation in Draft Tube

Experimental and Numerical Analysis of Pressure Pulsation in Francis Turbine

Simulation of unsteady flow in a Francis turbine draft tube

Comparisons of Vortical Flow and Cavitation Inside a Francis Turbine with Different Draft Tubes

Numerical Simulation and Analysis of the Internal Flow in A Francis Turbine with Air Admission

Simulation of Unsteady Flow Induced by in Vortices the Draft Tube of a Francis Turbine

Pressure Fluctuations in a Francis Turbine Draft Tube Calculated by Cavitating Flow Simulation

Analysis on characteristics of two-stage rotor-stator interaction and pressure fluctuation propagation in Francis turbine under partial load

Unsteady Turbulent Simulation of Three Gorges Hydraulic Turbine and Analysis of Pressure in the Whole Passage

Vorticity Dynamics Analysis On Flow In Francis Hydraulic Turbine

Experimental and Numerical Analysis of Pressure Pulses Characteristics in A Francis Turbine with Partial Load

Numerical Simulation of Pressure Vibrations in a Francis Turbine Draft Tube with Air Admission

Numerical Analyses of Pressure Fluctuations Induced by Interblade Vortices in a Model Francis Turbine

Experimental investigation on the characteristics and alleviation of the upper part load pressure fluctuation in a Francis turbine

DES SIMULATION ON FRANCIS TURBINE WITH NEW GUIDE VANES

Numerical prediction and similarity study of pressure fluctuation in a prototype Kaplan turbine and the model turbine

Numerical Simulation Of 3d Cavitating Turbulent Flow In Francis Turbine

Numerical Investigations of Solid-Liquid Two-Phase Turbulent Flows through Francis Turbine

Experimental and Numerical Simulation Study on the Flow Characteristics of the Draft Tube in Francis Turbine

Correlation Analysis of the Internal Vortex Flow of Hydro Turbine with the Pressure Fluctuation Inside Draft Tube