Abstract:The gas phase flow field inside a cyclone separator is crucial to the particle separation process. Previous studies have paid attention to the steady-state characteristics of the gas phase flow field, while research on its dynamic characteristics remains insufficient. Meanwhile, cyclone separators often adopt different structural forms according to the process requirements, the evolution laws of the dynamic characteristics flow field within them are still not well understood. Therefore, in this study, a hot-wire anemometer (HWA) was employed to measure the instantaneous tangential velocity of the gas phase flow fields within different structural cyclone separators (cylinder type, cylinder–cone (no hopper), and cylinder–cone (with hopper)). Comparative analyses and discussions were conducted regarding the dynamic characteristic distribution rules of the flow field in the time domain and the frequency domain. The results revealed that the dimensionless tangential velocity distributions of different types of cyclone separators all conformed to the Rankine vortex structure. The instantaneous tangential velocity fluctuated with low frequency and high amplitude, and the low-frequency velocity fluctuation exhibited a transfer behavior along the radial direction. Compared with the cylinder–cone-type cyclone separator, the tangential velocity in the cylinder-type cyclone separator fluctuated more greatly, and its quasi-periodic behavior was also more obvious. The time-averaged tangential velocity, the tangential velocity fluctuation intensity (Sd), and the dominant fluctuation frequency all had obvious attenuation along the axial direction in the cylinder-type cyclone separator, while the above-mentioned parameters had no attenuation along the axial direction in cylinder–cone-type cyclone separators. Additionally, the backflow from the hopper of the cylinder–cone-type cyclone separator (with hopper) led to an increase in the instantaneous tangential velocity fluctuation intensity of the local flow field near the dust outlet, as well as the occurrence of the "double dominant frequencies" phenomenon.

Analysis of Flow Field and Improved Design of Cyclone Separator with Downward Exhaust Gas

Numerical Simulation and Experimental Investigation of Flow Field in Gas-Liquid Cylindrical Separator with Baffle Configuration

Study on Separation Performance of Tri-Cone Water Medium Cyclone Based on CFD

Numerical Simulating the Gas-solid Flow in Square Cyclone With a Curved Inlet

Numerical simulation on structure optimization of escape-pipe of cyclone separator with downward outlet

Study of the performance and flow field of a new spiral-roof cyclone separator

Experimental investigation on separation characteristics of axial cyclone separator

Numerical analysis of a novel cascading gas-liquid cyclone separator

Comparative Analyses of Dynamic Characteristics of Gas Phase Flow Field Within Different Structural Cyclone Separators

Experimental study on the gas-solid two-phase flow in a square cyclone separator with downward gas exit by particle dynamic analyzer

Numerical investigation of separation efficiency of the cyclone with supercritical fluid–solid flow

The Structure Design And The Flow Field Analysis Of The Gas-Liquid Separation Cyclone

AN EXPERIMENTAL STUDY ON THE GAS-SOLID TWO-PHASE FLOW IN A SQUARE CYCLONE SEPARATOR WITH DOWNWARD GAS EXIT BY 3D-PDA

Numerical analysis on the influence of vortex motion in a reverse Stairmand cyclone separator by using LES model

ICONE19-43328 PERFORMANCE ANALYSIS OF CYCLONE SEPARATOR AND ITS OPTIMIZATION

Double-Eccentric Design for the Vortex Finder of a Cyclone Separator

Numerical simulation of the complex flow field in a new recycling cyclone separator

Numerical simulation of the particle-wall collision strength and swirling effect on the performance of the axial flow cyclone separator

NUMERICAL SIMULATION OF FLOW FIELD IN CYCLONE OF DIFFERENT HEIGHT

Numerical analysis of cyclone separators with unique Dipleg structures at different Dipleg-to-dustbin ratios

A study on gas flow in spiral inlet cyclone separator