Abstract:Production of polyhydroxyalkanoates (PHAs) by open mixed microbial cultures (MMCs) has been attracting increasing interest as an alternative technology to PHA production by pure cultures, due to the potential for lower costs associated with the use of open systems (eliminating the requirement for sterile conditions) and the utilisation of cheap feedstock (industrial and agricultural wastes). Such technology relies on the efficient selection of an MMC enriched in PHA-accumulating organisms. Fermented cheese whey, a protein-rich complex feedstock, has been used previously to produce PHA using the feast and famine regime for selection of PHA accumulating cultures. While this selection strategy was found efficient when operated at relatively low organic loading rate (OLR, 2g-CODL-1d-1), great instability and low selection efficiency of PHA accumulating organisms were observed when higher OLR (ca. 6g-CODL-1d-1) was applied. High organic loading is desirable as a means to enhance PHA productivity. In the present study, a new selection strategy was tested with the aim of improving selection for high OLR. It was based on uncoupling carbon and nitrogen supply and was implemented and compared with the conventional feast and famine strategy. For this, two selection reactors were fed with fermented cheese whey applying an OLR of ca. 8.5g-CODL-1 (with 3.8g-CODL-1 resulting from organic acids and ethanol), and operated in parallel under similar conditions, except for the timing of nitrogen supplementation. Whereas in the conventional strategy nitrogen and carbon substrates were added simultaneously at the beginning of the cycle, in the uncoupled substrates strategy, nitrogen addition was delayed to the end of the feast phase (i.e. after exogenous carbon was exhausted). The two different strategies selected different PHA-storing microbial communities, dominated by Corynebacterium and a Xantomonadaceae, respectively with the conventional and the new approaches. The new strategy originated a more efficient PHA-production process than the conventional one (global PHA productivity of 6.09g-PHAL-1d-1 and storage yield of 0.96 versus 2.55g-PHAL-1d-1 and 0.86, respectively). Dissociation between the feast to famine length ratio (F/F) and storage efficiency was shown to be possible with the new strategy, allowing selection of an efficient PHA-storing culture with complex feedstock under high organic loading rates.

Strategy to Reduce the Acclimation Period for Enrichment of Pha Accumulating Cultures

Evaluation of Polyhydroxyalkanoate Recovery from Food Waste by Sequencing Batch Biofilm Reactor with High Mixed Microbial Biomass

Optimization of an enriched mixed culture to increase PHA accumulation using industrial saline complex wastewater as a substrate

Effect of pH control and uncoupled carbon and nitrogen feeding strategy on enrichment of mixed microbial culture for polyhydroxyalkanoates production

Cultivation of polyhydroxybutyrate-rich aerobic granular sludge in a sequencing batch reactor

PHA and EPS production from industrial wastewater by conventional activated sludge, membrane bioreactor and aerobic granular sludge technologies: A comprehensive comparison

Polyhydroxyalkanoates (PHA) Production from Fermented Thermal-Hydrolyzed Sludge by PHA-storing Denitrifiers Integrating PHA Accumulation with Nitrate Removal.

PHA production from wastewater by mixed microbial culture under short-term microbial enrichment

Sludge minimization in municipal wastewater treatment by polyhydroxyalkanoate (PHA) production

Influence of the C/N ratio on the performance of polyhydroxybutyrate (PHB) producing sequencing batch reactors at short SRTs

Effect of enrichment conditions of secondary feeding on the synthesis of polyhydroxyalkanoates (PHAs) by activated sludge

Influence of Aeration Rate on Uncoupled Fed Mixed Microbial Cultures for Polyhydroxybutyrate Production

Effect of the organic loading rate on the PHA-storing microbiome in sequencing batch reactors operated with uncoupled carbon and nitrogen feeding

Cultivation of aerobic granules for polyhydroxybutyrate production from wastewater.

Production, downstream processing, and characterization of polyhydroxyalkanoates (PHAs) boosted by pyruvate supplement using mixed microbial culture (MMC) and organic wastewater

Analysis of Medium-Chain-Length Polyhydroxyalkanoate-Producing Bacteria in Activated Sludge Samples Enriched by Aerobic Periodic Feeding

Membrane Fouling Mitigation in MBR via the Feast–Famine Strategy to Enhance PHA Production by Activated Sludge

Nutrient Removal, Microbial Community and Sludge Settlement in Anaerobic/aerobic Sequencing Batch Reactors Without Enhanced Biological Phosphorus Removal.

Production of Polyhydroxyalkanoates (PHA) by Bacterial Consortium from Excess Sludge Fermentation Liquid at Laboratory and Pilot Scales

Promotion of polyhydroxyalkanoates-producing granular sludge formation by lactic acid using anaerobic dynamic feeding process

Strategies for efficiently selecting PHA producing mixed microbial cultures using complex feedstocks: Feast and famine regime and uncoupled carbon and nitrogen availabilities