Abstract:Nowadays, the zero liquid discharge of flue gas desulfurization (FGD) wastewater from coal-fired units has attracted the attention of all countries in the world. The pretreatment methods generally have the problems of high operation cost, small treatment capacity, and poor flexibility. However, the membrane method can avoid the above problems. In the current research, it has not been found that someone directly uses submerged ultrafiltration to pretreat FGD wastewater. Therefore, this paper innovatively proposed to directly use ceramic ultrafiltration membrane to treat FGD wastewater, which can ensure effluent quality and improve the flexibility of the pretreatment system. In this paper, the performance of submerged ultrafiltration membrane for the filtration of FGD wastewater from a power plant was studied to optimize the filtration performance and improve the effluent quality. The effects of operating parameters such as membrane permeate flux, aeration rate and filtration/backwashing time combination on the membrane performance were studied. The results showed that when the filtration/backwashing time combination was 15 min/30 s, with the increased in permeate flux from 55 L/(m2·h) to 100 L/(m2·h), the steady transmembrane pressure (TMP) increased from 39 kPa to 70 kPa, and the fouling rate increased significantly from 4.5 kPa/h to 7.3 kPa/h; When the aeration rate increased from 10 m3/(m2·h) to 30 m3/(m2·h), the membrane pollution was much reduced. Excessive aeration rate cannot further alleviate the membrane pollution, but also brought greater energy consumption; Increasing backwashing time can effectively inhibit the formation of gel layer on the surface of the membrane and prolong the initial stage of low-pressure operation; The rejection of suspended solids (SS) and turbidity of the equipment studied in this paper can reach more than 99% under various working conditions, which can satisfy the water quality requirements of the subsequent steps. The submerged ultrafiltration membrane was suitable for the pretreatment of FGD wastewater because it can ensure the quality of permeate under the premise of long-term operation.

Experimental Study on Zero Liquid Discharge (ZLD) of FGD Wastewater from a Coal-Fired Power Plant by Flue Gas Exhausted Heat

Process Development of Flue Gas Desulphurization Wastewater Treatment in Coal-Fired Power Plants Towards Zero Liquid Discharge: Energetic, Economic and Environmental Analyses

Primary Research of a New Zero-Liquid-Discharge Technology of Wet Flue Gas Desulfurization Wastewater by Low-Rank Heat from Flue Gas

The Technology of Coal-fired Flue Gas Dechlorination for Realizing Zero-discharge of Desulfurization Wastewater and Its Influences on Boiler

Waste Heat Utilization from Boiler Exhaust Gases for Zero Liquid Discharge of Desulphurization Wastewater in Coal-Fired Power Plants: Thermodynamic and Economic Analysis

A novel drying tower technology for zero liquid discharge of desulfurization technology

Experimental Study of a Zero Water Consumption Wet FGD System

Streamer Plasma Induced Ammonia Flue Gas Desulfurization

Study on Spray Evaporation Treatment of Desulfurization Wastewater

Numerical Simulation of Key Parameters of Zero Discharge System for WFGD Wastewater

Effect of n(Na+)/n(Cl-) on Semi-dry Dechlorination in Coal-fired Flue Gas to Realize Zero Emission of FGD Waste Water

Pilot-scale treatment of hypersaline coal chemical wastewater with zero liquid discharge

Operating experience of CFB semi-dry FGD with novel humidification technology in China

An integrated membrane- and thermal-based system for coal chemical wastewater treatment with near-zero liquid discharge

Migration and Agglomeration of Chlorine in Dechlorination of Coal-Fired Flue Gas

Pilot-scale study on seeded precipitation assisted nanofiltration for flue-gas desulfurization wastewater softening

Experimental study on latent heat and condensate recovery from flue gas in coal-fired power plants

Holographic Slurry Droplet Monitor: Design and Its Application to 1000 MW Coal-Fired Power Unit

Application of Submerged Ultrafiltration in Pretreatment of Flue Gas Desulfurization Wastewater

Treatment of Flue Gas Desulfurization Wastewater with Near-Zero Liquid Discharge by Nanofiltration-Membrane Distillation Process

Research on wet flue gas desulfurization by waste