Abstract:Highlights • The new extractant P12 has outstanding extractant efficiency for Fe 3+ in a highly concentrated phosphoric acid solution(pH=0.2). • The extraction mechanism and thermodynamics are obtained, extraction process involves both cation exchange and complexation of extractant. • The composition of the extract was obtained: [Fe(H2PO4)2.4A0.6(HA)0.84(H2O)](o) 、 [Fe(H2PO4)2.2A0.8(HA)1.12(H2O)](o) . • The stripping efficiency can reach 100% at 5.5 M HCl, and the extractant structure will not be destroyed. The new extractant (P12) was used to remove Fe 3+ from the simulated liquid of wet process phosphoric acid in this work. The solubility of P12 in white oil under the action of P204(Di-(2-ethylhexyl) phosphate) and n-octanol is discussed in detail. Then, the effects of reaction temperature, reaction time, the volume ratio of extraction phase and aqueous phase (O:A), pH of the phosphoric acid solution(simulated solution) and various anions on the extraction process were discussed. The extraction efficiency increases with the increase of extractant P12, the decrease of pH and the increase of O:A. Under the condition of pH=0.2, O:A= 1:1, the extraction efficiency of P12=5%, 7% and 9% can be up to 70.86%, 81.84% and 90.93% respectively. The extraction mechanism and extract composition were determined by slope method, FTIR and SEM. The ΔH < 0, ΔG < 0, ΔS < 0 in the extraction process proves that the extraction process was a spontaneous and exothermic process. The extraction mechanism proves that the extraction process involves both cation exchange and complexation of extractant. The composition of the extract may be [Fe(H2PO4)2.4A0.6(HA)0.84(H2O)](o) , [Fe(H2PO4)2.2A0.8(HA)1.12(H2O)](o) . And stripping efficiency of 5.5 M HCl can reach 100% at A:O=4:1, ΔH =38.9357 kJ/mol in stripping process prove that it is endothermic. Graphical abstract Download : Download high-res image (66KB) Download : Download full-size image

Mechanism and Kinetics Study on Removal of Iron from Phosphoric Acid by Cation Exchange Resin

Ion Exchange Treatment of Cobalt Acetate Solutions to Remove Iron(III) Impurity

Removal of Iron(III) and Aluminum Ions from Phosphoric Acid–Nitric Acid Solutions by S957 Chelation Resin: Kinetics, Dynamic Adsorption, and Elution

Remove and Recover Phosphorus During Anaerobic Digestion of Excess Sludge by Adding Waste Iron Scrap

Phosphorus Removal Using Ferric–calcium Complex As Precipitant: Parameters Optimization and Phosphorus-Recycling Potential

Comparison of Phosphorus Removal Processes by Ferrous Salts and Ferric Salts

Synthesis of hydrated ferric oxide on cation exchange resin for phosphate and hardness removal in water

Experimental Study on the Mechanism and Thermodynamics of Extraction of Fe 3+ from Phosphoric Acid Solution

Removal of Fluorine from Wet-Process Phosphoric Acid Using a Solvent Extraction Technique with Tributyl Phosphate and Silicon Oil

Mechanism and kinetics of iron removal in Fe-Al-H2SO4 system by coordination precipitation

Resin-based iron-manganese binary oxide for phosphate selective removal

Enhanced Removal of Pb2+ from Water by Adsorption Onto Phosphoric Acid-Modified Ps-Edta Resin: Mechanism and Kinetic Study

Speciation analysis and formation mechanism of iron-phosphorus compounds during chemical phosphorus removal process

Study on the Preparation of a Polydiethylene Phenyl Phosphate Resin and its Adsorption of Cu2+ in Wastewater

Removal of Pb2+ from Aqueous Solutions by a High-Efficiency Resin

Development of a Polyaluminum Ferric Titanium Chloride for Phosphorous Removal in Water

Removal of phosphorus in wastewater by sinusoidal alternating current coagulation: performance and mechanism

Phosphate removal from water by zero-valent iron / activated carbon fiber felt galvanic couples

Cooperation of ferrous ions and hydrated ferric oxide for advanced phosphate removal over a wide pH range: Mechanism and kinetics

Thermodynamic Modeling of Ferric Phosphate Precipitation for Phosphorus Removal and Recovery from Wastewater