Abstract:Magnetic shape memory CoNiGa alloys hold great promise as new smart materials due to the good ductility and a wide range of martensitic transformation (MT) temperatures as well as magnetic transition points. This paper reports the results of investigations on the equilibrium phase constitution and microstructure evolution in quenched or aged CoNiGa alloys using the optical microscopy (OM), scanning electron microscopy (SEM), X-ray diffraction (XRD) and transmission electron microscopy (TEM) methods. The dendritic γ phase decreases as lowering of Ga content in studied two series of samples (Co50Ni50−xGax, x=0–50 and Co100−2yNiyGay, y=15–35). Some γ′ precipitates with different morphologies were found in given alloys conducted with water quenching (WQ) at 800°C or long-time ageing at 300°C. After 800°C quenching, the γ′ phase has a rod-like shape for the Co50Ni30Ga20 alloy but shows a Widmanstätten morphology as Ga increases to 25at%, and trends to be block structure in further high Ga content alloy. In the case of 300°C aged alloys, the γ′ particles prefer to nucleate in interior of γ phase or at the interface of β–γ. We also presented an illustrative vertical section phase diagram keeping 50at% Co, and isothermal section phase diagram at 1150 and 800°C of the CoNiGa system. Based on the schematic ternary phase diagram, the composition scope which potentially holds over the magnetic pure martensite phase structure at room temperature (RT) was pointed out. It is believed that this optimized range alloys would play an important role in the functional materials design for application.

Microstructure and Phase Transformation of Ni-Mn-Ga Wires Produced by the in Rotating Water Melt-Spinning Technique

Microstructural Evolution of Ni–Mn–Ga Microwires During the Melt-Extraction Process

Structural, Magnetic and Mechanical Properties of Oligocrystalline Ni-Mn-Ga Shape Memory Microwires

Effect of Chemical Ordering Annealing on Martensitic Transformation and Superelasticity in Polycrystalline Ni–Mn–Ga Microwires

Martensitic Transition and Superelasticity of Ordered Heat Treatment Ni-Mn-Ga-Fe Microwires

Effect of chemical ordering annealing on Ni-Mn-Ga-Fe shape memory microwires

Superelasticity and Shape Memory Effects in Polycrystalline Ni–Mn–Ga Microwires

Improving Mechanical and Magnetocaloric Responses of Amorphous Melt-Extracted Gd-based Microwires Via Nanocrystallization

Microstructure of Surface and Subsurface Layers of a Ni-Ti Shape Memory Microwire.

Tailoring the Microstructure, Phase Transition Characteristics and One-Way Shape Memory Effect of Ni-Mn-Ga Alloys by Dual Treatment of Annealing and Directional Solidification

Damping Properties of Ni-Mn-Ga Microwires

Two-way Shape Memory Effect and Magnetic-Field-induced Twin Boundary Motion in Ni-Mn-Ga Microwire

Microstructure Evolution in CoNiGa Shape Memory Alloys

Study on phase transformation, internal stress and texture evolution of cold drawn Nb nanowire-NiTi composite wires upon annealing

Martensite Transformation and Superelasticity in Polycrystalline Ni–Mn–Ga–Fe Microwires Prepared by Melt-Extraction Technique

Microstructure and Martensitic Transformation Behavior of the Ni50mn36in14 Melt-Spun Ribbons

Shape Memory Effects of Ni49.7mn25.0ga19.8fe5.5 Microwires Prepared by Rapid Solidification

Influence of microstructure evolution on GMI properties and magnetic domains of melt-extracted Zr-doped amorphous wires with accumulated DC annealing

Manipulation of microstructure evolution and deformation behavior in Ni–Mn–Ga shape memory alloys with varied Ni/Ga under uniaxial cyclic compression

Suppression of γ phase and its effect on mechanical behavior of melt-spun and annealed Ni–Mn–Ga high-temperature shape memory alloys

Microstructural, phase transformation and magnetic properties of Ni - Mn - Ga alloy fabricated by spark plasma sintering