Abstract:Purpose As the service time of bridges increases, the degradation of bending capacity, the lack of safety reserves and the decrease in bridge reliability are common in early built bridges. Due to the defective lateral hinge joints, hollow slab bridges are prone to cracking of hinge joint between plates, transverse connection failure and stress of single plates under the action of long-term overload and repeated load. These phenomena seriously affect the bending capacity of the hollow slab bridge. This paper aims to describe a new method of simply supported hollow slab bridge reinforcement called polyurethane–cement (PUC) composite flexural reinforcement. Design/methodology/approach This paper first studies the preparation and tensile and compressive properties of PUC composite materials. Then, relying on the actual bridge strengthening project, the 5 × 20 m prestressed concrete simply supported hollow slab was reinforced with PUC composites with a thickness of 3 cm within 18 m of the beam bottom. Finally, the load test was used to compare the performance of the bridge before and after the strengthening. Findings Results showed that PUC has high compressive and tensile strengths of 72 and 46 MPa. The static test revealed that the measured values and verification coefficients of the measured points were reduced compared with those before strengthening, the deflection and strain were reduced by more than 15%, the measured section stiffness was improved by approximately 20%. After the strengthening, the lateral connection of the bridge, the strength and rigidity of the structure and the structural integrity and safety reserves were all significantly improved. The application of PUC to the flexural strengthening of the bridge structure has a significant effect. Originality/value As a new type of material, PUC composite is light, remarkable and has good performance. When used in the bending strengthening of bridge structures, this material can improve the strength, rigidity, safety reserve and bending capacity of bridges, thus demonstrating its good engineering application prospect.

Experimental Investigation of Axial Behavior of Strengthened Reinforced Concrete Columns Using Polyurethane-Cement(PUC)

Experimental research on seismic behavior of concrete-filled reactive powder concrete tubular columns

Compressive Behavior and Strength Prediction of Ultra-High Performance Concrete Confined by Normal and High Strength Steel Hoops

Experimental Research on Composite Action of Concrete-filled RPC Tube under Axial Load

STUDY ON REINFORCEMENT OF FABRICATED HOLLOW SLAB BRIDGE BY POLYURETHANE-CEMENT COMPOSITE (PUC)

Axial compressive performance of RC columns strengthened with prestressed CFRP fabric combined with UHPC jacket

Experimental and numerical study on axial compressive behaviors of reinforced UHPC-CFST composite columns

Experimental Study of Reinforced Concrete T-Beams Strengthened with a Composite of Prestressed Steel Wire Ropes Embedded in Polyurethane Cement (PSWR–PUC)

Flexural behavior of the corrugated steel-concrete composite structures with the polyurethane concrete (PUC)

Experimental study on the eccentrically compressive performance of square masonry columns repaired with UHPC jackets

Axial Behavior of Reinforced UHPC-NSC Composite Column under Compression

Study on static load test of simply supported hollow slab bridge flexural strengthened with polyurethane–cement composite

Experimental fire performance assessment of a new type of prestressed composite circular precast concrete columns

Compressive behavior of RC columns strengthened with FRP and prefabricated UHPC blocks

Seismic Behavior of Ultra-High Performance Concrete Short Columns Confined with High-Strength Reinforcement

Pseudo-Static Experiment and Analysis on Seismic Behavior of the RC Columns Strengthened by GHPFRCC

Seismic Performance Analysis of Concrete Columns Reinforced with Prestressed Wire Ropes Embedded in Polyurethane Cement Composites

Shear Behaviour of FRP-confined Concrete/uhpc Core-Encased Rebar: Experimental Investigation and Design Method

Research on uniaxial compressive behavior of high‐strength spiral stirrups confined circular ultra‐high performance concrete columns

Experimental study on the axial compressive performance of prefabricated steel reinforcement cage‐cast‐in‐situ concrete column with an innovative sleeve

Experimental, Numerical, and Analytical Studies of Uniaxial Compressive Behavior of Concrete Confined by Ultra-High-Performance Concrete