Abstract:The SAPO-34/ZSM-5 composite catalyst (SZ-TS) was successfully fabricated using a two-step in situ crystallization method. X-ray diffraction, Fourier-transform infrared spectroscopy, scanning electron microscopy, N2 adsorption–desorption, and ammonia temperature-programmed desorption measurements were used to characterize the synthesized catalysts and evaluate their catalytic performances on methanol-to-olefin (MTO) reaction. The synthesis mechanism of two-step in situ crystallization was further investigated. Results showed that the SZ-TS synthesized by two-step in situ crystallization featured an intimately bonded composite structure owing to the synergistic effects of the interface. However, the physical mixture of SAPO-34 and ZSM-5 (SZ-PM) presented two discrete phase structures. By using the composite catalyst in MTO reaction, the SZ-TS exhibited the longest life of 1400 min, which was much higher than that of SZ-PM (720 min). Methanol conversion reached 97.3%, and the selectivity for light olefins totalled 93.0%. The excellent catalytic performance of SZ-TS was attributed to the hierarchical pore structure and suitably weak acid site distribution. Via pre-crystallization, alkalinity can be adjusted in the adjacent ranges of SAPO-34 and ZSM-5. By adding the pre-crystallized alkaline SAPO-34 slurry into the strong alkaline system of the parent ZSM-5 slurry, phase dissolution of SAPO-34 in the secondary crystallization solution was avoided. The external surface of SAPO-34 was etched in the alkaline environment of the secondary crystallization solution, resulting in hierarchical pore distribution, which benefited the MTO reaction. This in situ synthesis method features the advantages of simplicity, low time consumption, and low cost. Therefore, this approach possesses the potential to satisfy the demands of the MTO market.

Facile Synthesis of Dimethyl Succinate Via Esterification of Succinic Anhydride over ZnO in Methanol

Insight into the green route to dimethyl succinate by direct esterification of bio-based disodium succinate using CO2 and CH3OH

Strong Cu/ZnO Interfacial Interaction Induced by ZrO2 Promoter Suppressing the Ethanol Formation in Industrial Methanol Synthesis

Regulating Surface Acid-Base Balance on NaZSM-5 by Fe Modification Towards Enhanced Methanol Dehydration to Dimethyl Ether

Ethylene glycol and ethanol synthesis from dimethyl oxalate hydrogenation on the Cu/ZnO/SiO2 catalysts

One-pot synthesis of dimethyl succinate from d-fructose using Amberlyst-70 catalyst

Highly Dispersed CrOx Nanoparticle-Modified NaZSM-5 for Dehydration of Methanol to Dimethyl Ether

Functional Specific Heteropoly Acid Ionic Liquid Catalyzed Direct Esterification of Aqueous Succinate Solution

Highly Selective Oxidation of Methanol to Dimethoxymethane over So42-/V2o5-Zro2

Regulating Surface Acid-Basic Balance on Nazsm-5 by Fe3+ Solution Towards Enhanced Methanol Dehydration

Facile in situ hydrothermal crystallization synthesis of SAPO-34/ZSM-5 composite catalyst for methanol to olefin reaction

Green Conversion of Saponins to Diosgenin in an Alcoholysis System Catalyzed by Solid Acid Derived from Phosphorus Tailings

A green and moderate approach for the synthesis of methyl formate via dimethoxymethane disproportionation over H-zeolites

Direct synthesis of ethanol from dimethyl ether and syngas over combined H-Mordenite and Cu/ZnO catalysts.

Ethanol Synthesis from Dimethyl Oxalate Hydrogenation on Cu/Sio2 Catalyst

One-Step Synthesis of Dimethyl Ether from Syngas with Fe-Modified Zeolite ZSM-5 as Dehydration Catalyst

One-step synthesis of dimethyl ether from biomass-derived syngas on CuO-ZnO-Al2O3/HZSM-5 hybrid catalyst: Combination method, synergistic effect, water-gas shift reaction and catalytic performance

Dehydration Reaction of Bio-Ethanol to Ethylene over Modified SAPO Catalysts

Local electron-rich structures facilitating the efficient synthesis of dimethyl carbonate from propylene carbonate and methanol over a ZnO/ZrO 2 solid solution catalyst

ZnxMg1‐xO Solid Solutions: Efficient Bifunctional Acid‐Base Catalyst for the synthesis of Methyl Ethyl Oxalate from Dimethyl Oxalate and Ethanol

Ethanol Synthesis from Dimethyl Oxalate Hydrogenation on Cu/SiO<sub>2</sub> Catalyst