Abstract:About 10wt.% of glycerol can be produced during the conversion of vegetable oils or animal fats into biodiesel fuel by the transesterification process. To make use of glycerol and increase its values, H2 production from catalytic steam reforming of glycerol by Ni–Mg–Al based catalysts was evaluated experimentally in a fixed-bed reactor under atmospheric pressure within a temperature range of 450–650°C. The thermodynamic analysis was conducted by using a non-stoichiometric methodology based on the minimization of Gibbs free energy. The Ni–Mg–Al based catalysts were synthesized by the co-precipitation method with rising pH technique. The synthesized catalysts were characterized by the elemental analysis, BET, XRD and SEM methods. All the metals in the catalyst remained in oxide forms and the catalysts had the specific surface areas from 98.542 to 126.777m2/g for different compositions. The results showed that glycerol conversion and H2 selectivity were increased with increasing temperatures from 450 to 650°C. The formations of CH4 and CO in the glycerol steam reforming were almost negligible. Carbon formation in glycerol steam reforming was serious in low temperatures. The catalyst containing NiO of 24.1wt.%, MgO of 26.1wt.% and Al2O3 of 49.8wt.% performed appreciable catalytic activity, and the H2 selectivity was found to be 78.5% and conversion of glycerol was up to 88.0% at 650°C. The effects of the operating conditions including temperature, the ratio of steam to carbon (S/C), glycerol inlet concentration and flow rate of carrier gas on glycerol steam reforming by the optimized catalyst were tested. Based on a kinetic model assuming the power law with a first reaction order, the activation energy and the frequency factor for glycerol steam reforming by the Ni–Mg–Al based catalysts were calculated.

Direct Production of Ethanol from Glycerol over Ni-substituted Stichtite Derived Catalysts

A Study on Catalytic Conversion of Biomass-Derived Carbohydrates to Methyl Lactate by NiO in Near-Critical Methanol

Enhancement of Catalytic Activity by Γ-Niooh for the Production of Methyl Lactate from Sugars in Near-Critical Methanol Solutions

Glycol Production from Sorbitol Hydrogenolysis over Hydrothermally Stable Ni Catalysts and the Mechanistic Study

Promoting Electrocatalytic Glycerol C─C Bond Cleavage to Formate Coupled with H2 Production Over a CuxNi2–xP Catalyst

Glycerol Hydrogenolysis over Supported Bimetallic Pt-Ni Catalyst

Reforming and Hydrogenolysis of Glycerol over Ni/ZnO Catalysts Prepared by Different Methods

Ni Doped Cu-ZnO Catalyst for Glycerol Hydrogenolysis

Steam reforming of ethanol over Ni/MgAl2O4 catalysts

CoZn-ZIF-derived ZnCo2O4-framework for the Synthesis of Alcohols from Glycerol

Efficient Catalytic Upgrading of Ethanol to Higher Alcohols via Inhibiting C–C Cleavage and Promoting C–C Coupling over Biomass-Derived NiZn@NC Catalysts

Enabling Direct-Growth Route for Highly Efficient Ethanol Upgrading to Long-Chain Alcohols in Aqueous Phase.

Hydrogen production from steam reforming of glycerol by Ni–Mg–Al based catalysts in a fixed-bed reactor

Boosting the selectivity of higher alcohols in upgrading of aqueous bioethanol over amphiphilic NiSn@C-MgO catalyst

Transformation of CO2 with Glycerol to Glycerol Carbonate over ETS-10 Zeolite-Based Catalyst

Ni-Based Hydrotalcite (HT)-Derived Cu Catalysts for Catalytic Conversion of Bioethanol to Butanol

Direct production of ethanol with high yield from glycerol via synergistic catalysis by Pd/CoOx and Cu/SBA-15

Ethylene glycol and ethanol synthesis from dimethyl oxalate hydrogenation on the Cu/ZnO/SiO2 catalysts

Enhanced Biomass-Derived Glycerol Conversion to Syngas in the CO 2 Reforming Process: Influence of the Nickel Loading Method on Physicochemical Properties and Catalytic Performance

Ethanol Steam Reforming by Ni Catalysts for H2 Production: Evaluation of Gd Effect in CeO2 Support

In-depth analysis of embedded-type structures of NixMg4-xAl LDO-composited catalysts and the impacts on glycerol conversion under a base- and H2-free condition