Abstract:The capture and sequestration of CO2 generated from large-scale stationary power plants is considered to be one of the leading technologies that could potentially have a significant impact on reducing greenhouse emissions. Among these emerging technologies, the oxy-fuel combustion is a near-zero emission technology that can be adapted to both new and existing pulverized coal-fired power stations. The goal of this work is to make a comparative study on char structural characteristics (including char yield, swelling ratio, BET surface area, pore distribution, morphology) and reactivity during conventional air and oxy-fuel combustion. Specific experimental designs include two series. One is carried out in pure N-2 and CO2 (pyrolysis experiments), and another is prepared in N-2+5%O-2 and CO2+5%O-2. Coal samples included raw coal, low density fraction coal and medium density fraction coal in all experiments. The present study is a further effort to extend our knowledge about physical and chemical structural characteristics and reactivity of char in the presence of high concentration CO2. Combustion and pyrolysis of a density fractionated China coal at drop tube furnace yielded the following conclusions. Compared to oxy-chars obtained under pure CO2 atmosphere, the swelling ratios of char obtained in pure N-2 atmosphere are higher. When adding 5% O-2, experimental results are completely different with those of the pyrolysis experiment. In comparison with the oxy-chars obtained under CO2 + 5%O-2 atmosphere, the swelling ratios of the char obtained in N-2 + 5%O-2 atmosphere are lower. In the pyrolysis experiment, the BET surfaces Area of the oxy-chars are about ten to twenty times as much as chars. When adding 5% O-2, the BET surfaces Area of the oxy-chars are about two to four times as much as chars. During pyrolysis experiment, the total pore volumes of the oxy-chars obtained under pure CO2 are larger in comparison with chars obtained in pure N-2. The pore distributions of the oxy-chars are mainly mesopore and the chars have macropore mostly. The micropore and mesopore volume of oxy-chars are about ten times as much as chars separately and the macropore volume of oxy-chars are about two times as much as chars. When adding 5% O-2, the total pore volumes of the oxy-chars obtained under CO2 + 5%O-2 are also larger in comparison with chars obtained in N-2 + 5%O-2. In the pyrolysis experiment, the reactivity indexes of oxy-chars obtained under pure CO2 are lower in comparison with chars obtained in pure N-2. When adding 5% O-2, no significant differences can be observed, which may be due to the ordering of carbon microcrystalline structure. In pure CO2 atmosphere, the oxy-chars have a highly order polycrystalline structure, but chars obtained at pure N-2 atmosphere have a highly disordered carbonaceous structure.

Impacts of CO2 on Char Structure and the Gasification Reactivity

Investigation into the Structural Features and Gasification Reactivity of Coal Chars Formed in CO 2 and N 2 Atmospheres

Effects of Pyrolysis Atmosphere and Temperature on Coal Char Characteristics and Gasification Reactivity

Structural Features and Gasification Reactivity of Coal Chars Formed in Ar and Co2 Atmospheres at Elevated Pressures

Assessment of the Impact of Pyrolysis Conditions on Char Reactivity Through Orthogonal Experimental-Based Grey Relational Analysis

Gasification Behavior and Kinetics of Chars Derived from Coal Pyrolysis in a CO-containing Atmosphere

Impacts of Char Structure Evolution and Inherent Alkali and Alkaline Earth Metallic Species Catalysis on Reactivity During the Coal Char Gasification with CO2/H2O

Structure and combustion reactivity of coal char pyrolyzed in different atmospheres

Effects of CO2 Atmosphere on Slow Pyrolysis of High-Ash Lignite

Effects of CO 2 /H 2 O on the Characteristics of Chars Prepared in CO 2 /H 2 O/N 2 Atmospheres

Effect of O2/CO2 combustion on coal char reactivity

Effects of CO2 on Coal Rapid Pyrolysis Behavior and Chemical Structure Evolution

Impact of CO 2 atmosphere on coal pyrolysis with internals

Effect of Sodium on the Structure and Reactivity of the Chars Formed under N-2 and Co2 Atmospheres

An Investigation Of The Structure And Gasification Reactivity Of Char

Comparison Of Char Structural Characteristics And Reactivity During Conventional Air And Oxy-Fuel Combustion

Effect of CO2 on pyrolysis behavior of Shengli lignite

Effects of CO2 on Gas Evolution and Char Structure Formation During Lump Coal Pyrolysis at Elevated Pressures

Structural Characterization of Char During Co-Gasification from Torrefied Sludge and Yangchangwan Bituminous Coal

Effects of CO Atmosphere on the Pyrolysis of a Typical Lignite

Combustion Behavior of Chars Derived from Coal Pyrolysis under a CO-containing Atmosphere