Abstract:For ac/dc power conversion applications like server power supply, telecom power supply, and on-board charger of an electric vehicle, the rising electricity demand has presented challenges toward high efficiency and high power density. The cascaded H-bridge (CHB) based multilevel power factor correction (PFC) converter has much higher power density than that of traditional boost PFC converter. However, the CHB-PFC converter has multiple floating dc outputs, which leads to a common mode (CM) electromagnetic interference (EMI) issue due to the parasitic capacitance of cascaded dc/dc stages and layouts and distributed noise sources existing in the ac/dc system. Thus, a large EMI filter is necessary for the PFC system that sharply degrades the system's power density. In order to quantify the CM noise caused by the floating outputs and cascaded parasitic capacitance, a unified equivalent CM circuit model is derived in this article, which decouples the effects among the multiple CM noise sources in the CHB converter. Based on the derived circuit model, a mirror-bridge phase-shift modulation is proposed to cancel the CM noise within the CHB converter itself. A single-phase 2-kW CHB PFC prototype has been built up to verify the analysis, and 40-dB CM noise reduction compared with conventional unipolar modulation is achieved by the proposed modulation scheme.

The Modular-Combined Three-Phase Pfc Converter Based on Improved Full-Bridge Structure

Study of a Single-stage Three-phase PFC DC/DC Converter With Series-parallel Connected Transforms

Soft-Switching Single Stage Isolated Ac-Dc Converter for Single-Phase High Power Pfc Applications

Soft-Switching Single-Stage Current-Fed Full-Bridge Isolated Converter for High Power Ac/Dc Applications

Three-Phase Seven-level H-bridge Commutated Active Clamped Converter

Output Characteristics Analysis of Phase Module Combined Three-Phase Single-Stage PFC Converter Based on Full-Bridge Structure

Single Stage PFC Circuit with Full Bridge Structure

Improved Three-Phase Single-Stage Isolated PFC Converter with Voltage-Clamping in Primary Side

Three Phase PFC Converter with Multilevel Inductive Switching Network

Three-phase Three-level PFC Rectifier Under Single-Cycle Control

A ZCS AC/DC CONVERTER WITH HIGH POWER FACTOR BASED ON PWM CONTROL STRATEGY

Research on a novel three-phase single-stage soft-switching PFC converter

A novel three-phase seven-level active clamped converter using H-bridge as a level doubling network

Study on the Topologies of Single-stage Full-bridge Active PFC

Mirror-Bridge Phase-Shift Modulation With Low Common-Mode Noise for Single-Phase CHB PFC

Mechanism and Suppression of Voltage Spike in a Three-Phase Single-Stage Full-Bridge PFC

A novel single-phase active-clamped ZVT-PWM PFC converter

Natural Power Factor Correction and Soft Switching Design for a Single-Stage Bidirectional Dual Active Bridge AC–DC Converter

A Novel Three-Phase Power Factor Correction Converter Based on Active Clamp Technique

Single-Phase Bridgeless Three-Level Power Factor Correction Topologies Based on the Embedded Construction Scheme

Asymmetric Modulation of Bridgeless Single‐stage Full‐bridge AC–DC Converter for Active Power Factor Correction and Zero Voltage Switching