Abstract:Ultra-small biomass gasification and power generation systems are a promising technology for disaster areas in developed countries and non-electrified rural areas of developing countries. The gasification characteristics of carbonized wood pellets and carbonized wood briquettes without or with 1 wt% sea salt were tested in a pilot-scale updraft fixed-bed gasifier. The results showed that the carbon balance during gasification was easily achieved, and most of the chlorine in the carbonized briquettes with sea salt remained in the residual char and fly ash after gasification. Inorganic chlorine in the solid fuel was transformed into organic chlorine combined with carbon matrix after heat treatment in the gasifier. Syngas with a low heating value higher than 4 MJ.m(-3) could be continuously obtained when the system reached a stable condition, which enabled power generation using a gas engine. A combination of several secondary tar removal processes was adopted for the syngas purification. The tar content in the syngas after the gas cleaning for 425 degrees C-carbonized pellet, 425 degrees C-carbonized briquette, 475 degrees C-carbonized briquette, and 475 degrees C-carbonized briquette with sea salt was 0.98, 0.26, 1.4, and 0.2 g.Nm(-3), respectively. During the stable stage, 425 degrees C-carbonized pellet showed the highest cold gas efficiency (CGE) of 45.6% and carbon conversion efficiency (CCE) of 57.8%, respectively, with an equivalence ratio (ER) of 0.24. A lower carbonization temperature showed a higher CGE and CCE. The residual char and fly ash after gasification could be considered for reuse as feedstock to further improve the overall process efficiency. The maximum output power was 23 kW at an air flow rate of 40 Nm(3)/h during the gasification of carbonized pellets, and the corresponding overall power generation efficiency of the engine using the syngas was about 27.8%. For 475 degrees C carbonized briquette, the maximum output power was 18 kW at an air flow rate of 40 Nm(3)/h, and the corresponding overall power generation efficiency of the engine using the syngas was about 25.5%.

Development of a Noval Ultra-small Biomass Gasification and Power Generation System

Mobile power generation system based on biomass gasification

Development of an Ultra-Small Biomass Gasification and Power Generation System: Part 2. Gasification Characteristics of Carbonized Pellets/briquettes in a Pilot-Scale Updraft Fixed Bed Gasifier

Development of an Ultra-Small Biomass Gasification and Power Generation System: Part 1. A Novel Carbonization Process and Optimization of Pelletization of Carbonized Wood Char

Techno-Environmental Analysis of the Use of Green Hydrogen for Cogeneration from the Gasification of Wood and Fuel Cell

D105 Development of an Efficient Small-scale Distributed Power Generation System Using Gasification of Woody Biomass(Biomass-2)

An experimental evaluation of an integrated biomass gasification and power generation system for distributed power applications

Comparative Study On The 1mw And 5.5mw Biomass Gasification And Power Generation System

Research and Application of Power Generation Project Based on Biomass Gas

Study Of Biomass Gasification And Combustion

Economics of Distributed Power Generation via Gasification of Biomass and Municipal Solid Waste

Comprehensive techno-economic investigation of biomass gasification and nanomaterial based SOFC/SOEC hydrogen production system

An Efficient Biomass and Renewable Power-to-gas Process Integrating Electrical Heating Gasification

Achieving near-zero emission and high-efficient combined cooling, heating and power based on biomass gasification coupled with SOFC hybrid system

Technical and Economic Assessments of a novel biomass-to-synthetic natural gas (SNG) process integrating O2-enriched air gasification

Renewable Energy Generation by Full-Scale Biomass Gasification System Using Agricultural and Forestal Residues

A feasibility analysis of distributed power plants from agricultural residues resources gasification in rural China

The development situation of biomass gasification power generation in China

Integrated Downdraft Gasification with Power Generation System and Gasification Bottom Ash Reutilization for Clean Waste-to-energy and Resource Recovery System

A Pilot Study on a 30t/h Biomass Gasification-Combustion Plant