Abstract:Gas explosion in connected vessels usually leads to high pressure and high rate of pressure increase which the vessels and pipes can not tolerate. Severe human casualties and property losses may occur due to the variation characteristics of gas explosion pressure in connected vessels. To determine gas explosion strength, an experimental testing system for methane and air mixture explosion in a single vessel, in a single vessel connected a pipe and in connected vessels has been set up. The experiment apparatus consisted of two spherical vessels of 350 mm and 600 mm in diameter, three connecting pipes of 89 mm in diameter and 6 m in length. First, the results of gas explosion pressure in a single vessel and connected vessels were compared and analyzed. And then the development of gas explosion, its changing characteristics and relevant influencing factors were analyzed. When gas explosion occurs in a single vessel, the maximum explosion pressure and pressure growth rate with ignition at the center of a spherical vessel are higher than those with ignition on the inner-wall of the vessel. In conclusion, besides ignition source on the inner wall, the ignition source at the center of the vessels must be avoided to reduce the damage level. When the gas mixture is ignited in the large vessel, the maximum explosion pressure and explosion pressure rising rate in the small vessel raise. And the maximum explosion pressure and pressure rising rate in connected vessels are higher than those in the single containment vessel. So whenever possible, some isolation techniques, such as fast-acting valves, rotary valves, etc., might be applied to reduce explosion strength in the integrated system. However, when the gas mixture is ignited in the small vessel, the maximum explosion pressures in the large vessel and in the small vessel both decrease. Moreover, the explosion pressure is lower than that in the single vessel. When gas explosion happens in a single vessel connected to a pipe, the maximum explosion pressure occurs at the end of the pipe if the gas mixture is ignited in the spherical vessel. Therefore, installing a pipe into the system can reduce the maximum explosion pressure, but it also causes the explosion pressure growth rate to increase. (C) 2013 Elsevier Ltd. All rights reserved.

Experimental Investigation on Explosion Flame Propagation of H 2 -O 2 in a Small Scale Pipeline

Experimental study on characteristics of flame propagation and pressure development evolution during methane-air explosion in different pipeline structures

Experimental Investigation And Numerical Simulation Of Gas Explosion In Linked Vessels

Research on Gas Explosion Pressure and Flame Propagation Characteristics in Turning Pipelines

Numerical study on the propagation of CH4/H2 flame in a pipeline under different H2 enrichment conditions

Experimental study on the propagation characteristics of hydrogen/methane/air premixed flames in a narrow channel

Flame Propagation and Spectrum Characteristics of CH4-air Gas Mixtures in a Vertical Pressure Relief Pipeline

Experimental Study of Effects of Ignition Position, Initial Pressure and Pipe Length on H-2-air Explosion in Linked Vessels

Study on effect of transverse concentration gradients in pipeline on methane explosion characteristics

MORPHOLOGY AND BURNING RATES OF EXPANDING SPHERICAL FLAMES IN H 2 / O 2 / INERT MIXTURES UP TO 60 ATMOSPHERES

Experimental Investigation On Microstructure And Propagation Behavior Of Propane/Air Flame

Effect of hydrogen addition on explosion characteristics of premixed methane/air mixture under different equivalence ratio distributions

Experimental investigation on spontaneous combustion of high-pressure hydrogen leakage to form jet fire

Study on explosion characteristics of hydrogen in a sudden expansion pipe

Comparative Study of the Effects of Ignition Location on the Flame Propagation Characteristics and Spectral Properties of a Methane–air Premixed Gas in a Vertical Pipeline

Premixed Flammable Gas Explosion in Containers Connected by Pipes with Different Lengths

Research on overpressure hazards and flame propagation behaviors of CH4/air mixture explosions in a vessel-duct connected device

The effects of different equivalence ratios and initial pressures on the explosion of methane/air premixed gas in closed space

Flame propagation characteristics of premixed hydrogen–air deflagration with low concentration in a pipeline

Experimental Investigation of Gas Explosion in Single Vessel and Connected Vessels

Outward Propagation, Burning Velocities, and Chemical Effects of Methane Flames Up to 60 ATM