Investigation on Decolorization of Biologically Pretreated Cellulosic Ethanol Wastewater by Electrochemical Method

Lili Shan,Junfeng Liu,John J. Ambuchi,Yanling Yu,Linlin Huang,Yujie Feng

DOI: https://doi.org/10.1016/j.cej.2017.04.121

IF: 15.1

2017-01-01

Chemical Engineering Journal

Abstract:The biologically pretreated cellulosic ethanol wastewater poses a serious environmental concern because of its refractory and color compounds. The decolorization of electrochemical oxidation using Sb doped Ti/SnO2 electrode for advanced treatment of cellulosic ethanol wastewater under different current density (5–30mA·cm−2), initial pH (3–8.9) and supporting electrolyte (0–0.25M NaCl) was investigated in this study. Complete decolorization, 8.5% chemical oxygen demand (COD) and 69.1% dissolved organic carbon removal efficiencies were achieved under the optimal conditions (20mA·cm−2, pH 5 and supporting electrolyte of 0.1M NaCl) after 150min. The energy consumption required to meet National Discharge Standard (GB 27631-2011) is 93.8kWhkg COD−1. Further investigation revealed that hydroxyl radicals played a primary role in the degradation of organic contaminants, while active chlorine formed from chloride oxidation played a less important role. Direct anodic oxidation and indirect reaction via peroxodisulfate generated from sulfate oxidation could be negligible. The formation of chlorination by-products appeared to be low since the final total Trihalomethanes concentration detected was 263µgL−1, with the detection of chloroform as the main Trihalomethanes.