Abstract:The physical properties of shale reservoirs are typically poor, necessitating the use of fracturing technology for effective development. However, the high clay content prevalent in shale formations poses significant challenges for conventional hydraulic fracturing methods. To address this issue, CO2-based fracturing fluid has been proposed as an alternative to mitigate the damage caused by water-based fracturing fluids. In this paper, the applicability of quasi-dry CO2 fracturing in shale reservoirs is examined from three key perspectives: the viscosity of CO2 fracturing fluid, the fracture characteristics induced by the CO2 fracture fluid, and the potential reservoir damage caused by the fracturing fluid. Firstly, the viscosity of CO2 fracturing fluid was determined by a rheological experiment. Rheological tests revealed that the viscosity of CO2 fracturing fluid was significantly influenced by the water–carbon ratio. Specifically, when the water–carbon ratio was 30:70, the maximum viscosity observed could reach 104 mPa·s. Moreover, increasing reservoir temperature resulted in decreased fracturing fluid viscosity, with a 40 °C temperature rise causing a 20% viscosity reduction. Secondly, matrix permeability tests were conducted to investigate permeability alteration during CO2 fracturing fluid invasion. Due to the weak acidity of CO2-based fracturing fluid, the permeability reduction induced by clay hydration was inhibited, and an increase in permeability was observed after a 3-day duration. However, the matrix permeability tends to decrease as the interaction time is prolonged, which means prolonged soaking time can still cause formation damage. Finally, triaxial fracturing experiments facilitated by a three-axis servo pressure device were conducted. The fracture properties were characterized using computed tomography (CT), and 3D reconstruction of fractured samples was conducted based on the CT data. The results demonstrate that CO2 fracturing fluid effectively activates weak cementation surfaces in the rock, promoting the formation of larger and more complex fractures. Hence, CO2 quasi-dry fracturing technology emerges as a method with significant potential, capable of efficiently stimulating shale reservoirs, although a reasonable soaking time is necessary to maximize hydrocarbon production.

Supercritical Carbon Dioxide Fracturing in Shale and the Coupled Effects on the Permeability of Fractured Shale: an Experimental Study

Surface characteristics and permeability enhancement of shale fractures due to water and supercritical carbon dioxide fracturing

Supercritical CO2 fracking for enhanced shale gas recovery and CO2 sequestration: results, status and future challenges

Chemical-Mechanical Coupling Effects on the Permeability of Shale Subjected to Supercritical CO 2-Water Exposure

Experimental Study on the Effect of Supercritical CO2 on Mechanical Properties and Fracture Characteristics of Longmaxi Shale

Effect of Supercritical Carbon Dioxide Fracturing on Shale Pore Structure

Thermomechanical coupling seepage in fractured shale under stimulation of supercritical carbon dioxide

The permeability of shale exposed to supercritical carbon dioxide

Simulation of Supercritical Carbon Dioxide Fracturing in Shale Gas Reservoir

Gas flow characteristics in shale fractures after supercritical CO2 soaking

The Permeability Alternation of Shale Fractures due to Sc-CO2 Soaking: Implications for Sc-CO2 Fracturing and Deep CO2 Sequestration in Shale Reservoirs

Experimental Study on the Fracture Behaviors Effect of Stress Conditions on the Fracture of Shale by Super-Critical Carbon Dioxide

Shale permeability and microstructural alternation during CO2 pre-fracturing: A mechanistic study

Further Investigation of CO2 Quasi-Dry Fracturing in Shale Reservoirs—An Experimental Study

Experimental Investigation on the Influence of Sub- and Super-Critical CO2 Saturation Time on the Permeability of Fractured Shale

Investigation on the Physics Structure and Chemical Properties of the Shale Treated by Supercritical CO2

A New Experimental Apparatus for Fracturing Shale Gas Reservoir to Enhance Permeability with Supercritical Carbon Dioxide

Influence of Supercritical CO 2 Fracturing Fluid on the Permeability of Shale Reservoir and Mechanism Analysis

Experimental Research on Supercritical Carbon Dioxide Fracturing of Sedimentary Rock: A Critical Review

Gas flow characteristics in shale fractures after supercritical CO<sub>2</sub> soaking

Experimental Study of Supercritical CO2 Fracturing on Initiation Pressure and Fracture Propagation in Shale under Different Triaxial Stress Conditions