Abstract:<p>The local phase distribution of adiabatic air-water two-phase flow in churn-turbulent to annular flows was experimentally investigated using the Two-Sensor Droplet-Capable Conductivity Probe. The experiments were performed in a 2.54 cm inner diameter vertical round pipe at downward flows. Twelve flow conditions in churn-turbulent to annular flows were chosen for the current study. The inlet superficial gas velocity ranged from 5.68 m/s to 17.19 m/s, and the inlet superficial liquid velocity ranged from 1.21 m/s to 2.64 m/s. The DCCP-2 is able to distinguish droplets, liquid ligaments, bubbles, and continuous gas. The radial profiles of volume fraction, frequency, axial interfacial velocity, and chord length of droplets, ligaments and bubbles were measured. The experimental results showed that gas volume fraction had a center-peak distribution, and the maximum gas volume fraction in centerline could exceed 95%. The volume fraction of droplets was very low, only on the order of 0.1 %. Droplet concentration also showed a center-peak distribution. Both ligament and bubble volume fraction showed a near-wall peak distribution. The ligament volume fraction in the near wall region could reach 80%, which indicated the existence of a film region near the wall and likely includes surface waves on the film. The volume fraction profile of gas, droplets, ligaments, and bubbles showed the tomography structure in churn-turbulent to annular flows. The effects of flow conditions on phase distribution were also studied. An interesting feature was that both the increase of gas flux and the increase of liquid flux tended to increase the bubble volume fraction. The statistical distribution of droplet size was found to be invariant of radial position. The droplet velocity at centerline was generally larger than the superficial gas velocity, which can be attributed to the gravitational effects at downward flows.</p>

Experimental Investigation of Two-Phase Slug Flow Distribution in Horizontal Multi-Parallel Micro-Channels

Liquid-liquid Two-Phase Flow and Mass Transfer in T-shaped Micro-Channel Network

Phase Distribution of Gas–Liquid Slug–Annular Flow in Horizontal Parallel Micro-Channels

WATER-OIL FLOW IN SQUARE MICROCHANNELS WITH A CROSSED JUNCTION

EFFECTS OF INLET ARRANGEMENTS ON LIQUID-LIQUID FLOW PATTERNS IN CROSS-JUNCTION SQUARE MICROCHANNELS

Effects of the Outlet Pressure on Two-Phase Slug Flow Distribution Uniformity in a Multi-Branch Microchannel

PRESSURE FLUCTUATIONS OF LIQUID-LIQUID SLUG FLOW IN CROSS-JUNCTION SQUARE MICROCHANNELS

Slug Formation Analysis of Liquid–Liquid Two-Phase Flow in T-Junction Microchannels

Experimental Observation of Slug Flow in Horizontal PDMS Micro-Channel

Experimental Investigation on Submerged Gas-Liquid Mixture Injection into Water Through A Micro-Channel

Nitrogen/non-Newtonian fluid two-phase upward flow in non-circular microchannels

Hydrodynamics and Local Mass Transfer Characterization under Gas–liquid–liquid Slug Flow in a Rectangular Microchannel

Investigation on Interphase Mixing and Flow Condensation Process in a Vertical Channel

Experimental Study on Vertically Upward Steam-Water Two-Phase Flow Patterns in Narrow Rectangular Channel

Study on Two-Phase Flow Pressure Drop and Mass Transfer in Parallel Microchannels

Experimental Investigation on Flow Regimes and Transitions of Steam-Water Two-Phase Flow in Narrow Rectangular Horizontal Channels

Ultrasonic oscillatory two-phase flow in microchannels

Experimental Investigations of Three-Dimensional Flow Field around the Head of Gas-Liquid Slug Flow in Microchannels

Numerical simulation and experimental investigation of gas-liquid two-phase flow in a complex microchannel

Experimental study of two-phase flow structure in churn-turbulent to annular flows

Experimental and Numerical Analysis on Heat Transfer Performance of Slug Flow in Rectangular Microchannel