Abstract:The transesterification of cellulose with vinyl esters in ionic liquid media is suggested as a prospective environmentally friendly alternative to conventional esterification. In this study, various long-chain cellulose esters (laurate, myristate, palmitate, and stearate) with a degree of substitution (DS) up to 1.8 have been synthesized in novel distillable ionic liquid, [mTBNH][OAC]. This IL has high dissolving power towards cellulose, which can improve homogeneous transesterification. Additionally, [mTBNH][OAC] has durability towards recycling and can be regenerated and re-used again for the next cycles of esterification. DMSO is used as a co-solvent because of its ability to speed up mass transport due to lower solvent viscosity. The optimization of the reaction parameters, such as co-solvent content, temperature (20–80 °C), reaction time (1–5 h), and a molar ratio of reactants (1–5 eq. AGU) is reported. It was found that within studied reaction conditions, DS increases with increasing reaction time, temperature, and added vinyl esters. Structure analysis using FTIR, 1H, and 13C NMR after acylation revealed the introduction of the alkyl chains into cellulose for all studied samples. The results also suggested that the substitution order of the OH group is C7-O6 ˃ C7-O2 ˃ C7-O3. Unique, complex thermal and rheological investigation of the cellulose esters shows the growth of an amorphous phase upon the degree of substitution. At the same time, the homogeneous substitution of cellulose with acyl chains increases the melt viscosity of a material. Internal plasticization in cellulose esters was found to be the mechanism for the melt processing of the material. Long-chain cellulose esters show the potential to replace commonly used externally plasticized cellulose derivatives.

Lipase‐catalyzed Synthesis of Long‐chain Cellulose Esters Using Ionic Liquid Mixtures As Reaction Media

One-Step Solvent-Free Strategy to Efficiently Synthesize High-Substitution Cellulose Esters

Preparation of Thermoplastic Cellulose Esters in [mTBNH][OAC] Ionic Liquid by Transesterification Reaction

Esterification of Cellulose with Long Fatty Acid Chain through Mechanochemical Method

Facile One-Pot Fabrication Of Cellulose Nanocrystals And Enzymatic Synthesis Of Its Esterified Derivative In Mixed Ionic Liquids

Enzymatic Transesterification of Kraft Lignin with Long Acyl Chains in Ionic Liquids

Continuous production of cellulose mixed esters via homogeneous reactive twin-screw extrusion catalyzed by ionic liquid

Rapid Synthesis of Cellulose Esters by Transesterification of Cellulose with Vinyl Esters under the Catalysis of NaOH or KOH in DMSO.

A Novel Transesterification System to Rapidly Synthesize Cellulose Aliphatic Esters

A One-Pot Method For Lipase-Catalyzed Synthesis Of Chitosan Palmitate In Mixed Ionic Liquids And Its Characterization

Effect of green co-solvents on properties and synthesis of cellulose esters in superbase ionic liquid

Plasticized Cellulosic Films by Partial Esterification and Welding in Low-Concentration Ionic Liquid Electrolyte

Lipase-Catalyzed Synthesis of Starch Palmitate in Mixed Ionic Liquids

Homogeneous Preparation in DMAc/LiCl and Characterization of Long-Chain Cellulose Esters

Tensile and Surface Wettability Properties of the Solvent Cast Cellulose Fatty Acid Ester Films

Enzymatic Synthesis of Glucose-Based Fatty Acid Esters in Bisolvent Systems Containing Ionic Liquids or Deep Eutectic Solvents

A New Method for Enzymatic Synthesis of Xylose Diester in Two-solvent Medium and its Structural Identification

Direct One-step Synthesis of Cellulose Laurate Ester Via Mechanochemical Method

Recent Progress in Lipase-Catalyzed Synthesis of Long-Chain Fatty Acid Starch Esters in Non-Aqueous Phase

Synthesis of Phase‐Selective Ionic Liquid Gels and Application to the Synthesis of Ethyl Acetate

Two-Step Method of Enzymatic Synthesis of Starch Laurate in Ionic Liquids