Abstract:Flame downwash behavior (flame pulled by the wake flow and attached to the leeward side of the nozzle) of gaseous fuel jets in cross-flow is of much practical importance in the design of burners as well as industrial flare, and thus important for energy conversion and conservation; however, the studies are still very limited. The critical condition (i.e., critical cross-flow air speed) for flame downwash occurrence as well as the evolution of flame downwash length for various fuel jet exit velocities has not been quantified yet. In this work, the flame downwash length evolution of non-premixed jets for different pipe nozzle diameters at various fuel discharge velocities and cross-flow air speeds as well as the critical condition under which the flame downwash occurs have been quantified comprehensively. Pipe nozzles with inner diameters of 8, 10, 13 and 15 mm were employed in the experiments, using propane as the fuel and with fuel jet velocities ranging between 0.38 and 2.42 m/s. The experimental results showed that the flame downwash length increased with increasing cross-flow air speed for a given fuel jet exit velocity. It was also found that, with increasing cross-flow air speed, the downwash length increased more rapidly for the higher fuel jet exit velocity than that for the lower fuel jet velocity. The critical cross-flow air speed, when flame downwash occurs, was found to be little dependent on the nozzle diameter but increase with the fuel jet exit velocity following a linear relationship. A new correlation for flame down wash length was proposed based on physically the coupling effects due to the competition of the fuel jet momentum to the cross-flow momentum and the total fuel mass supply. The proposed correlation was shown to well characterize the flame downwash length in terms of nozzle inner diameters, dimensionless fuel mass flow rates and the jet momentum ratio. The findings of this work provide basic knowledge and have potential practical applications for burner design and flare implementation, which allow predictions to be made regarding the possible threat and the establishment of the necessary safety length for the stack to prevent the damage for reducing the potential risk. (C) 2017 Published by Elsevier Ltd.

Soot Free Length Fraction of Buoyant Turbulent Non-Premixed Jet Flames in Normal- and a Sub-Atmospheric Pressure

Flame Size and Volumetric Heat Release Rate of Turbulent Buoyant Jet Diffusion Flames in Normal- and a Sub-Atmospheric Pressure

The Investigation of Soot Free Length of Jet Flame of Propane and Carbon Dioxide Gas Mixture

Intermittent flame lengths of buoyant jet flames in reduced and normal pressures: Experiments and theoretical analysis

Lift-off of jet diffusion flame in sub-atmospheric pressures: An experimental investigation and interpretation based on laminar flame speed

Sooting Tendencies of Propane Jet Diffusion Flame under Crossflow

Turbulent Jet Diffusion Flame Length Evolution with Cross Flows in a Sub-Pressure Atmosphere

A Comparison Between Direct Numerical Simulation and Experiment of the Turbulent Burning Velocity-Related Statistics in a Turbulent Methane-Air Premixed Jet Flame at High Karlovitz Number

Modeling of Supercritical-Pressure Turbulent Combustion of Hydrocarbon Fuels Using A Modified Flamelet-Progress-Variable Approach

Flame Morphology of Horizontal Jets under Sub-Atmospheric Pressures: Experiment, Dimensional Analysis and an Integral Model

Flame Heights and Fraction of Stoichiometric Air Entrained for Rectangular Turbulent Jet Fires in a Sub-Atmospheric Pressure

Lift-off Flames of Propane under a Variety of Co-Flow Conditions

An Experimental Study on Flame Envelope Morphologic Characteristics of Downward-Orientated Buoyant Turbulent Jet Fires

Flamelet LES of a Turbulent Pulverized Solid Fuel Flame Using a Detailed Phenomenological Soot Model

Flame Downwash Length Evolution of Non-Premixed Gaseous Fuel Jets in Cross-Flow: Experiments and a New Correlation

PAHs and Soot Formation in Laminar Partially Premixed Co-Flow Flames Fuelled by PRFs at Elevated Pressures

Characterization and Comparison of Flame Fluctuation Range of a Turbulent Buoyant Jet Diffusion Flame under Reduced- and Normal Pressure Atmosphere

Studying of Lifted Height of Jet Flame in Turbulent Combustion by Experiment

Flame height and lift-off of turbulent buoyant jet diffusion flames in a reduced pressure atmosphere

Flame Heights of Line-Source Buoyant Turbulent Non-Premixed Jets with Air Entrainment Constraint by Two Parallel Side Walls

Soot particles analysis in laminar premixed propane/oxygen (C3H8/O2) flames using published measurement data