Abstract:Ignition of iron particles in an oxidizing environment marks the onset of self-sustained combustion. The objective of the current study is to quantitatively examine the ignition characteristics of fine iron particles (i.e., 1µm- to 100µm-sized) governed by the kinetics of solid-phase iron oxidation. The oxidation rates are inversely proportional to the thickness of the oxide layer (i.e., following a parabolic rate law) and calibrated using the experimentally measured growth of iron-oxide layers over time. Steady-state (i.e., Semenov’s analysis) and unsteady analysis have been performed to probe the dependence of the critical gas temperature required to trigger a thermal runaway (namely, the ignition temperature T ign ) on particle size, initial thickness of oxide layer, inert gas species, radiative heat loss, and the collective heating effect in a suspension of particles. Both analyses indicate that T ign depends on δ 0 , i.e., the ratio between the initial oxide layer thickness and particle size, regardless of the absolute size of the particle. The unsteady analysis predicts that, for δ 0 ≲ 0.003 , T ign becomes independent of δ 0 . Under standard conditions in air, T ign is approximately 1080 K for any particle size greater than 5µm. The ignition temperature decreases as the thermal conductivity of the oxidizing gas decreases. Radiative heat loss has a minor effect on T ign . The collective effect of a suspension of iron particles in reducing T ign is demonstrated. The transition behavior between kinetic-controlled and external-diffusion-controlled combustion regimes of an ignited iron particle is systematically examined. The influences of initial oxide-layer thickness and particle temperature on the ignition delay time, τ ign , of iron particles are parametrically probed. A d 2 -law scaling between τ ign and particle size is identified. Possible sources of inaccuracy are discussed.

Ignition Characteristic Study on Some Combustibles under Various Atmosphere and Sample Size Conditions

Characterization on Ignition and Volatile Combustion of Dispersed Coal Particle Streams: in Situ Diagnostics and Transient Modeling

Investigations into the Ignition Behaviors of Pulverized Coals and Coal Blends in a Drop Tube Furnace Using Flame Monitoring Techniques

Ignition Characteristics of Typical Fitment Wood

Fire Spread over Charring Materials: Influence of the Sample Orientation and External Radiant Intensity

Experimental Study and Numerical Analysis on the Factors Concerning the Ignition Time of Timber

Experimental and theoretical analyses on ignition and surface temperature of dispersed coal particles in O2/N2 and O2/CO2 ambients

Influence of Particle Sizes on Combustion Characteristics of Coal Particles in Oxygen-Deficient Atmosphere

An experimental investigation on the effect of convection on the ignition behaviour of single coal particles under various O2 concentrations

An Experimental Study on Ignition of Single Coal Particles at Low Oxygen Concentrations

Influencing Factors and Mechanisms Involved in the Ignition of Low-Rank Coal: Implications for Spontaneous Combustion

Experimental And Numerical Analyses On Ignition And Burnout Characteristic Of Low-Rank Lignite And Semi-Char Blends

A quantitative analysis of the ignition characteristics of fine iron particles

Effect of Particle Size on the Kinetics of Pure Oxygen Combustion of Coke

Experimental research on ignition characteristics of pulverized coal

Numerical investigations on combustion characteristics of full-size cabin fire with typical material pyrolysis and burnout under different fire source positions

Research of combustion characteristic of car external decoration materials

Experimental Study on Effects of Burning Behaviours of Materials Caused by External Heat Radiation

Experimental and Numerical Investigations on Fire Development in a Timber-Based Compartment with Identification of Characteristic Events

Effect of Particle Size and Oxygen Content on Ignition and Combustion of Aluminum Particles

Experimental Research on Ignition Characteristics of Pulverized Coal under Pressurized O2/CO2 Atmosphere