Abstract:Aimed at the vibration of whole aero-engine, a coupled dynamic model of rotor-ball bearing-stator of aero-engine is built. By means of the lumped mass method, taking into account the nonlinear rub-impact, bearing failure force and deformation of the casing, the dynamic equation of the system containing typical rub-impact is derived. The response of the system under different conditions is obtained by using the fourth order Runge-Kutta numerical integration algorithm. By adopting the finite element analysis software ANSYS, the finite element model of the rotor shaft is established and the first six-order natural frequencies of the rotor system are acquired. Taking advantage of the parameters of the signal in time domain and frequency domain, frequency characteristics are extracted as the fault features. The single-point rubbing experiment is carried out in the test rig, and the working speed is higher than the first critical speed, so the rotor shaft is flexible rotor. By the methods of spectrum and cepstrum analysis, the rub-impact characteristics of the casing vibration acceleration time series data are analyzed. The results show that the casing vibration acceleration has obvious impact characteristics; the impact frequency is equal to the product of rotating frequency and number of the blades; the impact frequency component and its multiple-frequencies are demonstrated in the frequency spectrum; the strength of impact is modulated by the rotating frequency, so that there are families of side bands on impact frequency and both sides of frequency doubling, and the interval of sideband equals the rotating frequency. The frequency components of the rotating frequency and its frequency doubling are clearly shown in the cepstrum. By comparing the simulation and experiment, the rubbing characteristics found out in this paper has enough accuracy.

Dynamic Characteristics of Nonlinear Elastics Rotor System with Rub-impact Faults

Nonlinear Dynamics of a Rub-Impact Rotor Supported by Oil Film Bearings with an Elastic Stator

Vibration Analysis of a Nonlinear Rotor-Bearing-seal System

Modeling a Two-Span Rotor System Based on the Hamilton Principle and Rotor Dynamic Behavior Analysis

Stability of a Rub-Impact Rotor System

Experimental Investigation of Rotor Rubbing Faults

Periodic, quasi-periodic and chaotic vibrations of a rub-impact rotor system supported on oil film bearings

Dynamic Characteristics and Experimental Research of Dual-Rotor System with Rub-Impact Fault

Dynamic Analysis in Full Degrees of Freedom of Rotor’s Radial Rub-impact with the Consideration of Nonlinear Fluid-structure Interaction Forces

Chaotic behavior of a rub rotor model

Nonlinear Dynamic Analysis of a Rotor/bearing/seal System

Dynamics Behavior of Multi-Disk Flexible Rotor System with Transverse Crack

Analysis of Nonlinear Vibration Characteristics and Whirl Behavior of Dual-Rotor Systems with Inter-Shaft Rub Impact

Modeling and Nonlinear Dynamic Characteristics Analysis of Fault Bearing Time-Varying Stiffness-Flexible Rotor Coupling System

Nonlinear dynamic of the rod-fastening combined rotor system with rub-impact based on the Stribeck friction model

Dynamic Analysis of Rotor'S Radial Rub-Impact in Full Degrees of Freedom Accounting for Turborotor'S Non-Linear Clearance-Excitation Force

Dynamic analysis of slant cracked rotor system considering nonlinear oil film force

Nonlinear dynamic characteristics induced by inter-shaft rub-impact in a counter-rotational dual-rotor system of aeroengine

Dynamic Characteristics of Rotor System and Rub-Impact Fault Feature Research Based on Casing Acceleration

Vibration Response Analysis of Rubbing Faults on a Dual-Rotor Bearing System

Lubrication and stability analysis of nonlinear rotor-bearing system