Abstract:Mechanism experiments were performed to investigate NOr r formation and reduction during the combustion of high-ash, low-volatile coal. Additionally, industrial-scale trials were conducted to study the effects of air-staging degree on the combustion and NOr r emission characteristics of high-ash coal on a 350 MW supercritical down- fired boiler. The results showed that the total BET specific surface area, total pore volume and porosity values of high-ash coal (HAC) and ultra-high-ash coal (UHAC) were all larger than those of normal-ash coal (NAC), whereas NAC contained more N-5 and N-6 than HAC and UHAC. The carbon layer structure of HAC char was less ordered and the content of hydroxyl group was relatively high. The overall NO reduction ratio obtained using the HAC char was higher than the value for the UHAC char. However, in the high temperature range of 1300-1400 degrees C, NO reduction associated with UHAC char was accelerated because of catalysis by ash. On increasing the excess oxygen ratio lambda from 1.0 to 1.2, the char-N conversion shown by the UHAC char slowly increased and remained the lowest among the three chars. When burning UHAC, as the ratio of secondary to tertiary air fluxes, R st , was decreased from 1.56 to 0.57, heating of the fuel-rich coal/air flow slowed and pulverized coal combustion was inhibited. The situation associated with HAC was different. At the R st of 1.11, the ignition distance of fuel-rich flow was the shortest at 1.50 m, and the overall temperature in the furnace was the highest. However the NOr r emissions at the furnace exit were as high as 715 mg/m3 3 (6 % O2) 2 ) in this condition. Decreasing R st to 0.57 reduced this value to 634 mg/m3 3 (6 % O2) 2 ) with carbon levels in the fly ash and slag of 5.17 % and 3.67 %, respectively. Air-staging combustion is evidently a reasonable approach to controlling NOr r emissions when burning HAC. While for UHAC, it was necessary to appropriately reduce the air-staging degree to enhance combustion and maintain low NOr r emissions.

The Behavior of Nitrogen Oxides Emission of Stoker's Coal Bed with Different Excess Air Ratio

Study on the Emission Characteristics of Nitrogen Oxides with Coal Combustion in Pressurized Fluidized Bed

Experimental Study on Coal-Nitrogen Release and NO<i><sub>x</sub></i> Evolution in Oxygen-Enriched and Deep-Staging Combustion

NOx emissions of coal combustion in O2/CO2

Experimental Study on Nox Reduction from Staging Combustion of High Volatile Pulverized Coals. Part 1. Air Staging

Study of the Precipitation Characteristics of NO_x in the Coal Bed of a Laminar Combustion Boiler under Different Air Distribution Modes

Experimental Research on the Combustion and NO_x Generation Characteristics of Low Volatile Coal

The Investigation of NOx Formation and Reduction During O2/CO2 Combustion of Raw Coal and Coal Char

Study on the NOx Release Rule along the Boiler During Pulverized Coal Combustion

EXPERIMENTAL STUDY ON THE PROPERTY OF Nox EMISSION IN HIGH TEMPERATURE COMBUSTION OF COMMONLY USED COAL SORTS AND THEIR MIXTURES IN LARGE-SCALE TANGENTIALLY FIRING PULVERIZED COAL BOILERS

An Experimental Research on Boiler Combustion Performance

Studies on NO x formation and reduction characteristics in high-ash, low-volatile coal combustion by mechanism experiments and industrial-scale trials

TEST STUDY ON INFLUENCE OF AIR-DISTRIBUTING MODE FOR BURNERS UPON LOW EMISSION OF Nox

Effect of the Coal Blending Ratio on NOx Formation under Multiple Deep Air-Staged Combustion

Experimental Investigation on the NO2 Reduction Property under O2/CO2 Combustion Condition

NO_x Emissions of Coal Combustion in O_2/CO_2

Studies on NOx Formation and Reduction Characteristics in High-Ash, Low-Volatile Coal Combustion by Mechanism Experiments and Industrial-Scale Trials

Characteristics of NO Reduction by Char Layer in Fixed-Bed Coal Combustion

Experimental Investigation on NO Emission Characteristic During Pulverized Coal Combustion in O2/CO2 Environment

Experimental Study on NOx Formation and Reduction by Shenhua Coal During Combustion and Reburning

NO Reduction and Emission Characteristics of Coal/Char Mixtures in a Microfluidized Bed Reaction Analyzer