Abstract:Mechanism experiments were performed to investigate NOr r formation and reduction during the combustion of high-ash, low-volatile coal. Additionally, industrial-scale trials were conducted to study the effects of air-staging degree on the combustion and NOr r emission characteristics of high-ash coal on a 350 MW supercritical down- fired boiler. The results showed that the total BET specific surface area, total pore volume and porosity values of high-ash coal (HAC) and ultra-high-ash coal (UHAC) were all larger than those of normal-ash coal (NAC), whereas NAC contained more N-5 and N-6 than HAC and UHAC. The carbon layer structure of HAC char was less ordered and the content of hydroxyl group was relatively high. The overall NO reduction ratio obtained using the HAC char was higher than the value for the UHAC char. However, in the high temperature range of 1300-1400 degrees C, NO reduction associated with UHAC char was accelerated because of catalysis by ash. On increasing the excess oxygen ratio lambda from 1.0 to 1.2, the char-N conversion shown by the UHAC char slowly increased and remained the lowest among the three chars. When burning UHAC, as the ratio of secondary to tertiary air fluxes, R st , was decreased from 1.56 to 0.57, heating of the fuel-rich coal/air flow slowed and pulverized coal combustion was inhibited. The situation associated with HAC was different. At the R st of 1.11, the ignition distance of fuel-rich flow was the shortest at 1.50 m, and the overall temperature in the furnace was the highest. However the NOr r emissions at the furnace exit were as high as 715 mg/m3 3 (6 % O2) 2 ) in this condition. Decreasing R st to 0.57 reduced this value to 634 mg/m3 3 (6 % O2) 2 ) with carbon levels in the fly ash and slag of 5.17 % and 3.67 %, respectively. Air-staging combustion is evidently a reasonable approach to controlling NOr r emissions when burning HAC. While for UHAC, it was necessary to appropriately reduce the air-staging degree to enhance combustion and maintain low NOr r emissions.

Experimental Study on Nox Reduction from Staging Combustion of High Volatile Pulverized Coals. Part 1. Air Staging

Experimental Study on NO X Reduction from Staging Combustion of High Volatile Pulverized Coals. Part 2. Fuel Staging

Studies on NO x formation and reduction characteristics in high-ash, low-volatile coal combustion by mechanism experiments and industrial-scale trials

Studies on NOx Formation and Reduction Characteristics in High-Ash, Low-Volatile Coal Combustion by Mechanism Experiments and Industrial-Scale Trials

Effect Of Air-Staging On Anthracite Combustion And Nox Formation

Effect of Air-Staging on Anthracite Combustion and NO<i><sub>x</sub></i>Formation

NOx and SOx Emissions of a High Sulfur Self-Retention Coal During Air-Staged Combustion

Experimental Study on NO Emission and Ash Deposition During Oxy- Fuel Combustion of High-Alkali Coal under Oxygen-Staged Conditions

Experimental Study on NOx Formation and Burnout Characteristics of Pulverized Coal in Oxygen Enriched and Deep-Staging Combustion

Air-Staged Combustion Characteristics Of Pulverized Coal Under High Temperature And Strong Reducing Atmosphere Conditions

NOxEmissions and Nitrogen Fate at High Temperatures in Staged Combustion

Experimental Investigation of the Characteristics of NOx Emissions with Multiple Deep Air-Staged Combustion of Lean Coal

Study on NOx Emissions During the Coupling Process of Preheating-Combustion of Pulverized Coal with Multi-Air Staging

Experimental Study for Nox Reduction Using Four Chinese Pulverized Coals

Experimental Study on Influencing Factors of NOx Reduction by Combining Air Staging and Reagent Injection

Size Effect of Pulverized Shenhua Coal Particles on NOx Emission in Combustion with Air Staging

NOx Emission Characteristics of Superfine Pulverized Anthracite Coal in Air-Staged Combustion

Experimental Study on Effects of Air-Staged Strategy and NH3 Co-Firing Ratios on NO Formation Characteristics in Ammonia/coal Co-Firing Process

Effect of Staging Combustion on NOx Reduction in Stoker Boiler

Optimization of Air Staging in a 1 MW Tangentially Fired Pulverized Coal Furnace

Numerical Study of NOx Formation Characteristics on the 35 MW Staged Oxy-Coal Combustion