Abstract:Mechanism experiments were performed to investigate NO x formation and reduction during the combustion of high-ash, low-volatile coal. Additionally, industrial-scale trials were conducted to study the effects of air-staging degree on the combustion and NO x emission characteristics of high-ash coal on a 350 MW supercritical down-fired boiler. The results showed that the total BET specific surface area, total pore volume and porosity values of high-ash coal (HAC) and ultra-high-ash coal (UHAC) were all larger than those of normal-ash coal (NAC), whereas NAC contained more N-5 and N-6 than HAC and UHAC. The carbon layer structure of HAC char was less ordered and the content of hydroxyl group was relatively high. The overall NO reduction ratio obtained using the HAC char was higher than the value for the UHAC char. However, in the high temperature range of 1300–1400 °C, NO reduction associated with UHAC char was accelerated because of catalysis by ash. On increasing the excess oxygen ratio λ from 1.0 to 1.2, the char-N conversion shown by the UHAC char slowly increased and remained the lowest among the three chars. When burning UHAC, as the ratio of secondary to tertiary air fluxes, R st , was decreased from 1.56 to 0.57, heating of the fuel-rich coal/air flow slowed and pulverized coal combustion was inhibited. The situation associated with HAC was different. At the R st of 1.11, the ignition distance of fuel-rich flow was the shortest at 1.50 m, and the overall temperature in the furnace was the highest. However the NO x emissions at the furnace exit were as high as 715 mg/m 3 (6 % O 2 ) in this condition. Decreasing R st to 0.57 reduced this value to 634 mg/m 3 (6 % O 2 ) with carbon levels in the fly ash and slag of 5.17 % and 3.67 %, respectively. Air-staging combustion is evidently a reasonable approach to controlling NO x emissions when burning HAC. While for UHAC, it was necessary to appropriately reduce the air-staging degree to enhance combustion and maintain low NO x emissions.

NOx Emission Characteristics of Superfine Pulverized Anthracite Coal in Air-Staged Combustion

Research on Nitrogen Oxides Release Performance of Superfine Pulverized Coal Combustion

Combustion and NOx Emission Behavior of Chinese Coals

NO Emissions from Oxidizer-Staged Combustion of Superfine Pulverized Coal in the O2/CO2 Atmosphere

Experimental Investigation of Super Fine Pulverized-coal Reburning Technology for Reducing NOx emissions

Experimental Study on Nox Reduction from Staging Combustion of High Volatile Pulverized Coals. Part 1. Air Staging

Study on NOx Emissions During the Coupling Process of Preheating-Combustion of Pulverized Coal with Multi-Air Staging

E306 EXPERIMENTAL STUDY ON PERFORMANCE OF COMBUSTION AND NO EMISSION FOR LOW VOLATILIZATION COALS

Experimental Study on NO X Reduction from Staging Combustion of High Volatile Pulverized Coals. Part 2. Fuel Staging

Study on Co-combustion Characteristics of Superfine Coal with Conventional Size Coal in O&lt;sub&gt;2&lt;/sub&gt;/CO&lt;sub&gt;2&lt;/sub&gt; Atmosphere

Experimental Investigation of the Characteristics of NOx Emissions with Multiple Deep Air-Staged Combustion of Lean Coal

Study on Combustion Characteristics of Two Sizes Pulverized Coal in O2/CO2 Atmosphere

Study on the new pulverized coal economical fineness based on the NOxemission characteristics of Shenhua Coal

Experimental study of NO_x emissions from coal combustion under oxy-fuel conditions

Study On Combustion Performance With A Wide Range Of Coal Qualities

Experimental Study for Nox Reduction Using Four Chinese Pulverized Coals

Experimental study on low NOx combustion technology of pulverized coal

NO emission characteristics of superfine pulverized coal combustion in the O2/CO2 atmosphere

Studies on NO x formation and reduction characteristics in high-ash, low-volatile coal combustion by mechanism experiments and industrial-scale trials

Experimental and Simulation Study on Ultra-Low NOx Emissions of Anthracite by Preheated Combustion

Detailed in-furnace measurements with reburning of superfine pulverized coal in high CO2 concentration