Abstract:Pyrolysis of 11 coals with carbon contents of 77–93 wt.% (daf) and corresponding demineralized samples has been studied in a fixed bed quartz reactor with a heating rate of 20 K/min to examine rank, demineralization, temperature and inherent mineral species dependences of nitrogen distribution. Nitrogen mass balances fall within 92.5–104.6%. The results indicate that the chars derived from the coals with higher rank show larger nitrogen retention. Demineralization suppresses volatile nitrogen emission during coal pyrolysis, especially for low rank coals. Coal-N conversion to tar-N reaches the asymptotic values at 600 °C. HCN yields are lower than NH3 yields during coal pyrolysis. The trends in HCN and NH3 emissions are very similar and the yields reach the asymptotic value at about 1200 °C. N2 starts emitting at 600 °C, and as the temperature increases the conversion increases linearly with a corresponding reverse change of char-N. With the catalysts added, N2 formation is prompted with the sequence of Fe>Ca>K>Ti≫Na≫Si≈Al, meanwhile, char-N decreases correspondingly. Fe, Ca, K, Na, Si and Al increase coal-N conversion to NH3 with the sequence of Fe>Ca>K≈Na≫Si≈Al in the pyrolysis. Na addition prompts HCN formation; however, the presence of Ti and Ca decrease the HCN yields with small value. The other catalysts have no notable influence on HCN emission in the pyrolysis. Demineralization and Ti addition increase coal-N conversion to tar-N slightly whereas K, Ca, Mg, Na, Si and Al additions decrease tar-N yield weakly, other catalysts hardly influence tar nitrogen emission. N2 emits mainly from char-N with slight contribution of volatile nitrogen. The mechanism of different N-containing species formation and catalysts influence in the pyrolysis is also discussed in the paper.

Effect of Mineral Matter on Transformation of Nitrogen During Coal Conversion

Experimental Study of Effects of Pulverized Coal Characteristics on the Conversion of Fuel Nitrogen to NOx

Effect of Rank, Temperatures and Inherent Minerals on Nitrogen Emissions During Coal Pyrolysis in a Fixed Bed Reactor

Effect of Inherent Minerals on the Release of Fuel-Nitrogen During Coal Pyrolysis

Experimental Investigation on the Conversion of Nitrogenous Gas Products During Coal Pyrolysis

Effect of Ammonia on N Migration and Transformation Characteristics During Coal Pyrolysis: Quantum Chemical Calculations and Pyrolysis Experiments

Experimental Investigation on Char Nitrogen Conversion During Coal Pyrolysis

Nitrogen Conversion During Rapid Pyrolysis of Coal and Petroleum Coke in a High-Frequency Furnace

Influences of Hydrothermal Modification on Nitrogen Thermal Conversion of Low-Rank Coals

Molecular dynamics investigation of the effect of ammonia on coal pyrolysis and the nitrogen transformation

Effects of Minerals on the Release of Nitrogen Species from Anthracite

Fuel nitrogen evolution during coal pyrolysis and gasification

Coupling effect of Fe-based catalyst on Nitrogen oxides control in the process of nitrogen reduction and combustion denitration of long flame coal pyrolysis

EFFECTS OF MINERALS AND SODIUM ADDITION ON NITROGEN RELEASE DURING COAL COMBUSTION

Experimental Investigation on N2 Formation During Pyrolysis of Fushun Coal

Investigation on Fuel-N Transformation Properties of Coal/Biomass Heating Process in CO2 Atmosphere

The Effect Mechanism of Fe on Coal Pyrolysis to NO x Precursors: Quantum Chemical Calculations and Mass Spectrometry Experiments

Effects of Some Factors on the Formation of Nox Precursors During the Pyrolysis of Shenmu Coal

Experimental study on conversion characteristics of anthracite and bituminous coal during preheating-gasification

Mechanism of Mineral Fe on Fuel-N Oxidation During Ammonia-Coal Co-Combustion: Experimental and Quantum Chemistry Study

Combustion characteristics and nitrogen conversion mechanism in ammonia/coal Co-firing process