Abstract:Magnetic sensors actuated by bulk acoustic wave (BAW) have attracted extensive attention due to the fact of their high sensitivity, GHz-level high frequency, and small size. Different from previous studies, suppression of energy loss and improvement in energy conversion efficiency of the BAW magnetoelectric (ME) sensor were systematically considered during the device design in this work. Finite element analysis models of material (magnetic composite), structure (ME heterostructure), and device (BAW ME magnetic sensor) were established and analyzed in COMSOL software. Additionally, the magnetic composite was prepared by radio frequency magnetron sputtering, and its soft magnetism was characterized by magnetic hysteresis loop and surface roughness. The research results demonstrate that after inserting four layers of 5 nm Al2O3 films, a performance of 86.7% eddy current loss suppression rate, a less than 1.1% magnetostriction degradation rate, and better soft magnetism were achieved in 600 nm FeGaB. Furthermore, compared with other structures, the two-layer piezomagnetic/piezoelectric heterostructure had a better ME coupling performance. Eventually, the design of the BAW ME magnetic sensor was optimized by the resonance-enhanced ME coupling to match the resonance frequency between the magnetic composite and the BAW resonator. When a 54,500 A/m direct current bias magnetic field was applied, the sensor worked at the first-order resonance frequency and showed good performance. Its linearity was better than 1.30%, the sensitivity was as high as 2.33 μmV/A, and the measurement range covered 0–5000 A/m.

Magnetoelectric Coupling by Acoustic Wave Guide

Resonance magnetoelectric effect in a composite ferromagnet–dielectric–piezoelectric Langevin-type resonator

Resonance Magnetoelectric Effect in Radially Polarized Long Cylindrical Composite Structures

Magnetoelectric BAW and SAW Devices: A Review

Magnetoelectric Effect in Shear-Mode Pb(Zr,Ti)O3/NdFeB Composite Cantilever

Using magnetoelectric effect to reveal magnetization behavior of bulk and heavy ferromagnetic materials

Giant Magnetoelectric Effect of A Hybrid of Magnetostrictive and Piezoelectric Composites

Magnetoelectric Coupling of Laminated Composites under Combined Thermal and Magnetic Loadings

Magnetoelectric coupling of a magnetoelectric flux gate sensor in vibration noise circumstance

Continuum Shielding and Flow Dynamics in Active Galactic Nuclei

Eddy-Current Effect on Resonant Magnetoelectric Coupling in Magnetostrictive-Piezoelectric Laminated Composites

Design and Optimization of a BAW Magnetic Sensor Based on Magnetoelectric Coupling

Magnetoelectric Properties of A Heterostructure of Magnetostrictive and Piezoelectric Composites

Magnetoelectric Coupling of Multiferroic Composites under Combined Magnetic and Mechanical Loadings

Large magnetoelectric effect in mechanically mediated structure of TbFe2, Pb(Zr,Ti)O3 and nonmagnetic flakes

The Nonlinear ME Effect of FeNiMoSiB/ PZT-5A Composite under Step Magnetic Field Excitation for Magnetic Field Sensing

Magnetoelectric surface acoustic wave resonator with ultrahigh magnetic field sensitivity

Self-biased magnetoelectric sensor operating in d 36 face-shear mode

Large room temperature magnetoelectric response in quasi 1–2 nanocomposite films on mica substrate

A Novel Cylindrical Torsional Magnetoelectric Composite Based Ond15shear-Mode Response

Mechanical-Resonance-Enhanced Thin-Film Magnetoelectric Heterostructures for Magnetometers, Mechanical Antennas, Tunable RF Inductors, and Filters