Abstract:In this paper we reported the rheological and microstructural properties of a kind of novel cold, gel-like soy protein isolate (SPI) emulsions obtained by means of microfluidization. These gel-like emulsions were formed from untreated and preheated (95 °C, 15 min) SPI at a protein concentration of 6% (w/v), and various oil volume fractions (Φ; 0.2–0.6) and NaCl concentrations (0–500 mM). The rheological properties and microstructure were characterized using steady viscosity and dynamic oscillatory measurements, as well as confocal laser scanning microscopy (CLSM). The characteristics (e.g. droplet size distribution and creaming stability) of the emulsions, formed at lower protein concentrations (e.g. 0.5–4.0%), were also characterized, aiming to reveal the mechanism of the gel-like network formation. The dynamic oscillatory data indicated that both untreated and preheated SPI emulsions exhibited gel-like rheological properties, but the specific apparent viscosity (η) and storage modulus (G′) of the latter ones were much higher at a comparable Φ. Both η and G′ progressively increased upon Φ increasing, indicating enhanced inter-droplet interactions. At a given Φ value (0.3), increasing NaCl concentration progressively increased η and G′ of the preheated SPI emulsions, indicating the importance of electrostatic screening for the gel-like network formation. The CLSM analyses confirmed formation of the gel-like network, mainly composed of aggregated oil droplets, which was closely dependent on the Φ and NaCl concentration. The gel-like network was formed by bridging flocculation of oil droplets, mainly through inter-droplet hydrophobic interactions between the proteins adsorbed at the interface. These results suggested that soy proteins exhibit excellent potential to produce cold, gel-like emulsions, especially through a heat pretreatment followed by microfluidization, which might be of vital importance for the development of soy protein-based formulations, especially as carriers for heat-labile ingredients with health effects.

Textural and Rheological Properties of Soy Protein Isolate Tofu-Type Emulsion Gels: Influence of Soybean Variety and Coagulant Type

Impact of soy proteins, hydrolysates and monoglycerides at the oil/water interface in emulsions on interfacial properties and emulsion stability

Investigating the effects of oil type, emulsifier type, and emulsion particle size on textured fibril soy protein emulsion-filled gels and soybean protein isolate emulsion-filled gels

Analysis of the gel properties, microstructural characteristics, and intermolecular forces of soybean protein isolate gel induced by transglutaminase

Mechanical and Water-Holding Properties and Microstructures of Soy Protein Isolate Emulsion Gels Induced by CaCl2, Glucono-δ-lactone (GDL), and Transglutaminase: Influence of Thermal Treatments Before And/or after Emulsification

Physicochemical properties of soya bean protein gel prepared by microbial transglutaminase in the presence of okara

Formation and Properties of Glycinin-Rich and Β-Conglycinin-rich Soy Protein Isolate Gels Induced by Microbial Transglutaminase

Non-linear Rheological Properties of Soy Protein Isolate Dispersions and Acid-Induced Gels

Effects of covalent interactions and gel characteristics on soy protein-tannic acid conjugates prepared under alkaline conditions

Transglutaminase-set Soy Globulin-Stabilized Emulsion Gels: Influence of Soy Β-Conglycinin/glycinin Ratio on Properties, Microstructure and Gelling Mechanism

The Preparation of W/O/W High-Internal-Phase Emulsions as Coagulants for Tofu: The Effect of the Addition of Soy Protein Isolate in the Internal Water Phase

Gel Texture Property of Soybean Protein Isolates From Cultivars with Different Protein Subunit Contents

Cold, gel-like soy protein emulsions by microfluidization: Emulsion characteristics, rheological and microstructural properties, and gelling mechanism

Gelation Properties of Tofu Induced by Different Coagulants: Effects of Molecular Interactions Between Nano-Sized Okara Dietary Fiber and Soybean Proteins

The heated-induced gelation of soy protein isolate at subunit level: Exploring the impacts of α and α′ subunits on SPI gelation based on natural hybrid breeding varieties

Characterization and in vitro digestibility of soybean tofu: Influence of the different kinds of coagulant

Improvement of the rheological and textural properties of calcium sulfate-induced soy protein isolate gels by the incorporation of different polysaccharides

Enhancing the Gelation Behavior of Transglutaminase-Induced Soy Protein Isolate(SPI) through Ultrasound-Assisted Extraction

Freeze-thaw stability of transglutaminase-induced soy protein-maltose emulsion gel: Focusing on morphology, texture properties, and rheological characteristics

Improvement of kefir fermentation on rheological and microstructural properties of soy protein isolate gels

Study of Properties of Soy Protein-Stabilized Emulsion Gels Induced by Microbial Transglutaminase