Abstract:In this paper, the flotation separation of quartz and feldspar was studied with CaCl 2 as activators and mixed sodium oleate/ dodecylamine (NaOL/DDA) collectors under alkaline condition, and the action mechanism of mixed NaOL/DDA collectors on the quartz and feldspar surfaces were systematically explored. The results of micro-flotation test showed that there were 90.98% quartz and 13.08% feldspar were floated with 0.5 mmol/L CaCl 2 and 2.8 mmol/L mixed NaOL/DDA collectors with molar ratio of 8/1 at pH 10.0. And the artificial mixed minerals flotation manifested these two minerals were able to efficient separation with CaCl 2 and mixed NaOL/DDA collectors at pH 10 ∼ 11. These outcomes indicated that DDA could increase recovery of quartz obviously and reduce about a half dosage of NaOL (from 0.5 mmol/L to 0.25 mmol/L) in flotation under alkaline condition; Meanwhile, mixed NaOL/DDA collectors were able to decreased the flotation separation pH from 12 to 10 on quartz and feldspar. Infrared spectroscopy (FTIR) and X-ray photoelectron spectroscopy (XPS) results revealed that when NaOL collector was added alone, it could adsorb on activated quartz surface but hardly detected on feldspar surface at pH 10. However, they all were found on both quartz and felspar surface when mixed NaOL/DDA collectors were introduced as collectors. Quartz microcrystal balance with dissipation (QCM-D) experiment confirmed that mixed NaOL/DDA collectors showed a higher adsorption mass and more stable adsorption layer on quartz compared with NaOL was introduced as collector alone. In addition, whether CaCl 2 , NaOL or mixed NaOL/DDA, the adsorption mass on quartz sensor were larger than that on feldspar senor, which might cause difference of hydrophobicity on the surface of quartz and feldspar in flotation. The above experiments showed that the mixed NaOL/DDA collectors can significantly improve hydrophobic difference between quartz and feldspar after activating with CaCl 2 and expand the floated pH range of quartz compared with using NaOL as collector alone, which were efficient reagents to separate quartz and feldspar in flotation.

Novel insights into the role of colloidal calcium dioleate in the flotation of calcium minerals

New insights into the role of calcium dioleate in selectively separating fluorite from calcite during cleaning process

Effects of Pb2+ Ions on the Flotation Behavior of Scheelite, Calcite, and Fluorite in the Presence of Water Glass

Insights into the influence of calcium ions on the adsorption behavior of sodium oleate and its response to flotation of quartz: FT-IR, XPS and AMF studies

Effect of Ca(II) on anionic/cationic flotation of magnesite ore

Synergistic Effect of Sodium Dodecyl Benzene Sulfonate on Flotation Separation of Magnesite and Dolomite with Sodium Oleate Collector

Effects of Interfacial Hydroxylation Microstructure on Quartz Flotation by Sodium Oleate

Selective Flotation Separation of Fluorite from Calcite Using Mixed Anionic/cationic Collectors

Quantifying bubble-scheelite interaction under the effect of sodium oleate

Adsorption mechanisms of activated surface of quartz and feldspar with mixed NaOL/DDA

Understanding the activation mechanism of Ca2+ ion in sodium oleate flotation of spodumene: A new perspective

An integrated experimental and computational investigation of N ,9,10-trihydroxyoctadecanamide as a potential collector for the flotation separation of fluorite and calcite

The effect of calcium ions on the flotation behavior of fluorapatite

Flotation behavior of oleate and dodecylamine as mixed collector for recovery of lithium and rubidium from low-grade spodumene tailings: Experiment, characterization and DFT calculation

Effect of calcium lignosulfonate on the interaction forces between fine calcite and fluorite

Enhanced flotation separation of fluorite and calcite using novel collector: Experimental and theoretical Insights

Effects of the Crystal Structures of Three Calcium-Containing Minerals on Their Surface Characteristics in Flotation

Effect and Mechanism of Depressant CK102 on Flotation Separation of Fluorite and Dolomite

Quantitative analysis of surface adsorption reactivity during flotation process by surface complexation model: diaspore and kaolinite

Surface complexation model theory application in NaOL and CTAB collector adsorption differences of diaspore and kaolinite flotation

Effect of Ca2+ dissolution and migration transformation from phosphorite on the surface properties of dolomite