Abstract:While microalgae are promising biomass candidates for biodiesel production, efficient lipid extraction is hindered by the strong cell walls. Cell wall disruption is an essential processing step for improving lipid yields from microalgae biomass. Conventional methods use toxic organic solvents (e.g., mixtures of chloroform and methanol or hexane) to extract microalgal lipids. This study with Chlorella pyrenoidosa investigates a novel microalgal pretreatment by a deep eutectic solvent (choline chloride:acetic acid) to increase cell wall disruption prior to lipid extraction. Deep eutectic solvent and ultrasonic homogenization should be best performed after 5 min of pretreatment. Biomass was characterized before and after the pretreatment to understand the mechanism. To optimize the lipid extraction yield, the effect of various variables (methanol to n-butanol, solvent to biomass ratio, time, and temperature) on lipid extraction yield was investigated using a single-factor experiment. The maximum lipid yield (19.25%) was extracted at 1:4 methanol to n-butanol and a 30 (v/w) solvent to biomass ratio over 120 min at 60 °C. Fatty acid methyl esters were obtained through transesterification reactions from extracted lipid of optimized condition and biodiesel quality was studied in comparison with European and US standards. The dominant fatty acids were C16:0 (29.54%), C18:2 (18.42%), and C18:3 (19.50%) and properties of biodiesel are within the European and US standards. This novel pretreatment method, coupled with lipid yields and characterization, documents the significant potential for microalgae biodiesel as an alternative, sustainable energy source.

Continuous Production of Biodiesel from Microalgae by Extraction Coupling with Transesterification under Supercritical Conditions

In Situ Ethyl Ester Production from Wet Algal Biomass under Microwave-Mediated Supercritical Ethanol Conditions

Subcritical water extraction of lipids from wet algae for biodiesel production

High Quality Biodiesel Production from a Microalga Chlorella Protothecoides by Heterotrophic Growth in Fermenters

Biodiesel Production from Heterotrophic Microalgal Oil.

Extraction of microalgae oil and further production for second-generation biodiesel

Microalgal synthesis of the biodiesel employing simultaneous extraction and esterification via heterogeneous catalyst

Microalgae biomass pre-treatment with deep eutectic solvent to optimize lipid isolation in biodiesel production

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

Solvent-free Lipid Extraction from Microalgal Biomass with Subcritical Water in a Continuous Flow Reactor for Acid-Catalyzed Biodiesel Production

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

New insights to direct conversion of wet microalgae impregnated with ethanol to biodiesel exploiting extraction with supercritical carbon dioxide

Large‐scale Biodiesel Production from Microalga Chlorella Protothecoides Through Heterotrophic Cultivation in Bioreactors

Efficient Biodiesel Conversion From Microalgae Oil Of Schizochytrium Sp.

Direct Biodiesel Production from Wet Microalgae Biomass Ofchlorella Pyrenoidosathroughin SituTransesterification

High-Density Fermentation of Microalga Chlorella Protothecoides in Bioreactor for Microbio-Diesel Production

STUDY ON PREPARATION OF BIODIESEL FROM MICROALGAL OIL

Production of a sustainable fuel from microalgae Chlorella minutissima grown in a 1500 L open raceway ponds

Using wet microalgae for direct biodiesel production via microwave irradiation

Production of Microalgal Lipids As Biodiesel Feedstock with Fixation of CO2 by Chlorella Vulgaris.

Cost-effective biodiesel production from wet microalgal biomass by a novel two-step enzymatic process.