Abstract:This work presents studies on the combustion of Composite Biomass Pellets (CBPS) in fluidized bed using bauxite particles as the bed material. Prior to the combustion experiment, cold-flow characterization and thermogravimetric analysis are performed to investigate the effect of air velocity and combustion mechanism of CBPS. The cold-state test shows that CBPs and bauxite particles fluidize well in the fluidized bed. However, because of the presence of large CBPs, optimization of the fluidization velocity is rather challenging. CBPs can gather at the bottom of the fluidized bed at lower gas velocities. On the contrary, when the velocity is too high, they accumulate in the upper section of the fluidized bed. The suitable fluidization velocity for the system in this study was found to be between 1.5-2.0m/s. At the same time, it is found that the critical fluidization velocity and the pressure fluctuation of the two-component system increase with the increase of CBPs mass concentration. The thermogravimetric experiment verifies that the combustion of CBPs is a first-order reaction, and it is divided into three stages: (i) dehydration, (ii) release and combustion of the volatile and (iii) the coke combustion. The combustion of CBPs is mainly based on the stage of volatile combustion, and its activation energy is greater than that of char combustion. During the combustion test, CBPS are burned at a 10kg/h feed rate, while the excess air is varied from 25% to 100%. Temperatures of the bed and flue gas concentrations (O2, CO, SO2 and NO) are recorded. CBPs can be burnt stably, and the temperature of dense phase is maintained at 765-780°C. With the increase of the air velocity, the main combustion region has a tendency to move up. While the combustion is stable, O2 and CO2 concentrations are maintained at about 7%, and 12%, respectively. The concentration of SO2 in the flue gas after the initial stage of combustion is nearly zero. Furthermore, NO concentration is found to be closely related to O2: the NO reaches its peak value after initial stage and later decreases with the continued depletion of O2. Towards the end of combustion, NO increases with the increase of O2.

Co-combustion of anthracite coal and wood pellets: Thermodynamic analysis, combustion efficiency, pollutant emissions and ash slagging.

Optimization of the co-combustion of coal and composite biomass pellets

Experimental Study on Combustion Behaviors and Carbon Monoxide Emission Characteristics of Single Coal Pellets

Pollutant Emission and Attrition Performance of Low Calorific Blended Coals During Co-Combustion in Fluidized Bed

Experimental Studies on the Emission of Gaseous Pollutants in an Oxy-Fuel-Fluidized Bed with the Cofiring of Coal and Biomass Waste Fuels

Experimental Tests on Co-Firing Coal and Biomass Waste Fuels in a Fluidised Bed under Oxy-Fuel Combustion

Behavior of Slagging Deposits During Coal and Biomass Co-combustion in a 300 Kw Down-Fired Furnace

Co-combustion of Coal and Composite Board Sawdust: Combustion Behaviors, Ash Slagging Characteristics, and Gaseous Pollutant Emissions and Control

Effect of gaseous agents on co-combustion characteristics of sewage sludge and coal

Co-combustion of Bituminous Coal and Biomass Fuel Blends: Thermochemical Characterization, Potential Utilization and Environmental Advantage.

Co-combustion of wheat straw and camphor wood with coal slime: Thermal behaviour, kinetics, and gaseous pollutant emission characteristics

Experimental Studies on Combustion of Composite Biomass Pellets in Fluidized Bed.

Comprehensive study on co-combustion behavior of pelletized coal-biomass mixtures in a concentrating photothermal reactor

Combustion and Heat Transfer Characteristics of Co-Firing Biomass and Coal under Oxy-Fuel Condition

Thermodynamics and synergistic effects on the co-combustion of coal and biomass blends

Investigation on Co-Combustion of Coal Gasification Fine Ash and Raw Coal Blends: Thermal Conversion, Gas Pollutant Emission, and Kinetic Analyses

Modelling the Co-Firing of Coal and Biomass in a 10 Kwth Oxy-Fuel Fluidized Bed

Numerical and Experimental Study on Oxy-fuel Coal and Biomass Co-firing in the Bubbling Fluidized Bed

Investigation on Gaseous Pollutants Emissions During Co-Combustion of Coal and Wheat Straw in a Fluidized Bed Combustor.

Experimental Studies On Co-Combustion Of Sludge And Wheat Straw

Co-Combustion of Oil Shale Retorting Solid Waste with Cornstalk Particles in A Circulating Fluidized Bed