Abstract:The co-firing of various ultra-low volatile coal-based solid wastes (CSWs) under oxy-fuel condition is a promising approach to elevate the energy conversion efficiency in coal chemistry industry. However, the kinetics and thermal transformation mechanisms during oxy-fuel co-combustion of various CSWs blends are still vague, which need to be further elucidated. Here, the physical–chemical features of CSWs were firstly revealed. Moreover, the oxy-fuel co-combustion characteristics and kinetics of various CSWs were investigated. The results illustrate that four chemical forms of fuel nitrogen could be obtained in pyrolyzed semi-coke (PS), while only two occurrence forms of fuel nitrogen were observed in two residual carbons, including fluidized bed gasification residual carbon (FRC) and coal-water-slurry gasification residual carbon (CRC). The reactivities of various samples could be promoted by the increasing temperature during gasification process. The combustion of volatile matter and fixed carbon could be promoted by an increase in oxygen content in oxy-fuel atmosphere. The combustion characteristic index (S) of 50% PS/50% CRC is raised by 59.3% and that of 50% PS/50% FRC is increased by only 19.0% with the oxygen concentration elevated from 30 to 40%. The effects of rising residual carbon proportion on PS/CRC blend are more obvious than those on PS/FRC blend. The additive of PS in blend could promote the combustion behaviors of residual carbon, especially on CRC. The mass loss rate of 50% PS/50% CRC blend changes significantly with the heating rate, which is greater than that of 50% PS/50% FRC blend. The average apparent activation energy (Eam) of 50% PS/50% CRC blend is lower than that of linear calculation result. The Eam of CRC could be reduced by blending PS, and the poor combustion behaviors of CRC are improved by addition of PS.Graphic abstract

Co-combustion of Coal and Composite Board Sawdust: Combustion Behaviors, Ash Slagging Characteristics, and Gaseous Pollutant Emissions and Control

Investigation of the Characteristics of Catalysis Synergy During Co-Combustion for Coal Gasification Fine Slag with Bituminous Coal and Bamboo Residue

Evaluation of the Thermal Behavior, Synergistic Catalysis, and Pollutant Emissions During the Co-Combustion of Sewage Sludge and Coal Gasification Fine Slag Residual Carbon

Synergistic Co-Combustion of Carbon-Rich Fraction from Coal Gasification Fine Slag and Corncob Char: Performance, Mechanism, Kinetics, and Thermodynamics

Co-combustion of wheat straw and camphor wood with coal slime: Thermal behaviour, kinetics, and gaseous pollutant emission characteristics

Thermodynamics and synergistic effects on the co-combustion of coal and biomass blends

Study of Combustion Characteristics and Matching Between the Blends of Gasification Fine Slag and Coal with Varied Ranks

On the Co-Combustion Characteristics and Kinetics of Sludge, Wood Chips, and Bituminous Coal

Sludge Acts As a Catalyst for Coal During the Co-Combustion Process Investigated by Thermogravimetric Analysis

Co-combustion Characteristics and CO2 Emissions of Low-Calorific Multi-Fuels by TG-FTIR Analysis

Co-combustion of Coal and Carbonaceous Wastes: Thermogravimetric Analysis

Behavior of Slagging Deposits During Coal and Biomass Co-combustion in a 300 Kw Down-Fired Furnace

Co-combustion of sewage sludge and Zhundong coal: Effects of combustion conditions on gaseous pollutant emission and ash properties

Combustion characteristics and typical pollutant emissions of corn stalk blending with municipal sewage sludge

Investigation on co-combustion of coal gasification fine slag residual carbon and sawdust char blends: Physiochemical properties, combustion characteristic and kinetic behavior

Comprehensive Experimental Investigations on Co-combustion Dynamics and Multi-pollutant Formation Characteristics of Coal Gangue and Biomass in Oxy-fuel Atmosphere

Co-combustion of carbon-rich fraction from coal gasification fine slag and biochar: Gas emission, ash sintering, heavy metals evolutions and environmental risk evaluation

Oxy-fuel co-combustion characteristics and kinetics of various ultra-low volatile coal-based solid waste blends

Experimental and Numerical Investigation of the Combustion Characteristics and NO Emission Behaviour During the Co-Combustion of Biomass and Coal

Synergistic effect and volatile emission characteristics during co-combustion of biomass and low-rank coal

Comprehensive study on co-combustion behavior of pelletized coal-biomass mixtures in a concentrating photothermal reactor