Abstract:The Zhundong coalfield has attracted ever-increasing attention as a result of its super-large reserve of coal resources. However, the power plants encounter great challenges in the utilization of Zhundong coal as a result of its high-alkali feature, which deteriorates the phenomenon of ash deposition and slagging. Oxy-fuel combustion of Zhundong coal benefits the near-zero emission of pollutants in coal-fired power plants, while previous studies mainly focused on the behaviors of alkali and alkaline earth metals and ash deposition during air combustion. The present study focused on the characteristics of ash deposition during oxy-fuel combustion of high-alkali coal, especially the differences in morphologies and chemical compositions of ash deposits using a drop-tube furnace, with the ash deposition mechanisms being further elucidated. Experimental results showed that the contents of sulfur (S), chlorine (Cl), and calcium (Ca) in ash deposits from oxy-fuel combustion were lower at the identical O-2 content but the contents of aluminum (Al) and silicon (Si) were increased in comparison to air conditions. The average particle size of ash deposits under oxy-fuel conditions was smaller with less calcium sulfate and mullite than the case in air combustion of Zhundong coal. The adhesion phenomenon between ash particles was aggravated in the ash deposits of high-alkali coal, with the oxygen content elevated. The proportion and diameters of spherical particles declined with an increasing oxygen concentration in the ash deposits of Zhundong coal. The contents of iron (Fe) and calcium in ash deposits of high-alkali coal were closely bound with the decrease of the melting point of ash and the formation of spherical ash particles. The caking phenomenon became more serious as the flue gas temperature was increased in the ash deposits of Zhundong coal. The deposition propensity of Zhundong coal was inclined to the minimum when the probe surface temperature was 550 degrees C, while the deposition propensity of Lu'an coal was different possibly as a result of the differences in coal properties and ash compositions. During the combustion of high-alkali coals, some components deteriorated ash deposition, including the low-temperature eutectics formed by the reactions of Fe and Ca with Si-Al compounds and sulfates and chlorides of sodium or calcium. This paper is beneficial for the improved understanding of ash deposition during oxy-fuel combustion of high-alkali coal.

Study of Ash Fusion Behavior of Shenhua Coale During Oxygen Enriched Combustion

Experimental Study of Ash Formation under O-2/CO2 Combustion

Ash Deposition in Oxy-Fuel Combustion of Shenhua Coal

Effect of Chemical Compositions on Ash Fusibility Characterization of a Jincheng Anthracite During Combustion and Gasification

Study on the Coal Ash Fusibility During Blending Coal Combusition

Experimental Research on the Characteristics of Ash in Oxy-Fuel Combustion

Study on the Slagging Characteristics of Shenhua Coal under Oxygenenriched Combustion

Research on the slagging behaviors of Shenhua coal in different combustion atmospheres

Research on the Slagging Characteristics of Shenhua Coal

Study on the Ash Deposition Propensity and Mechanism of Shenhua Coal

Quantitative analysis of minerals of blended coal ash at high temperature and its influence on slagging

Effect of CaO/Fe2O3 Ratio on Fusibility of Coal Ashes with High Silica and Alumina Levels and Prediction

Ash Fusion Behaviors and Physicochemical Characteristics of High-Alkali Coals under Oxy-Fuel Condition

Effects of Ash Compositions in Zhundong Coal on Its Ash Fusion Behavior and Crystal Phase Transformation

Ash Fusion Regulation Mechanism of Coal with Low Melting Point and Different Ash Compositions

Iron-Bearing Minerals of Shenhua Coals and Their Conversion During Pulverized Coal Combustion

Ccsem Analysis Of Ash From Oxyfuel Combustion Of Zhundong Coal

Ash Fusion Characteristics Under Complex Atmosphere in Coal Combustion Process

Investigation on Ash Deposition Characteristics During Zhundong Coal Combustion

Mineral Conversion of Coal-ash in Fusing Process and the Influence to Ash Fusion Point

Experimental Study on Morphology and Chemical Composition of Ash Deposition During Oxy-fuel Combustion of High-Alkali Coal