Abstract:Unsteady numerical studies were conducted on the effects of combustor exit total pressure non uniformity and hot streak (HS) on the aero-thermal characteristics of a high-pressure (HP) turbine stage. Firstly, four total pressure profiles including uniform, turbulent boundary layer, realistic engine combustor exit and radial reverse total pressure (higher total pressure near the endwall) were applied to reveal the vortex structures and heat transfer characteristics of the turbine. Then the four total pressure profiles coupled with inlet HS were specified to study the HS migration mechanisms. The results indicated that the turbulent boundary layer total pressure intensifies the passage vortices (PVs) while the higher total pressure near the endwall induces counter rotating vortices (CRVs), in both the stator and rotor passages. The heat transfer on the vane and blade surfaces was affected by the vortices and the extent of the impact directly depends on the intensity of the vortices, which is determined by the gradient of the total pressure. The heat transfer coefficients (HTCs) on the vane and blade pressure surface are increased by 104% and 20-30%, respectively, due to the CRV effects. The increase of tip leakage flow for the higher total pressure near the tip enhances the tip pressure side HTC by 4% comparing with the uniform case. The PVs and CRVs from the stator passage persistently exist in the rotor passage near the suction side endwall while have negligible influence on the rotor heat transfer. The migration paths of the hot streak are significantly affected by the PVs and CRVs in the stator passage, and the rotor blade surface temperature is dominated by both of the redistribution of HS in the vane passage and the vortices in the rotor passage. The PVs extend the HS radial migration and increase the vane and blade surface temperature. While the CRVs circulate the hot fluid away from the vane surface and increase the HS attenuation, thus decrease the vane and blade surface temperature significantly. The total pressure non-uniformity also decreases the turbine adiabatic efficiency by 0.6% at uniform inlet temperature condition. (C) 2016 Elsevier Ltd. All rights reserved.

Influence of Reynolds Number on the Unsteady Aerodynamics of Integrated Aggressive Intermediate Turbine Duct

Numerical Investigation of the Effects of Rising Angle on Intermediate Turbine Duct and Nearby Turbines

Design performance evaluation and vortex structure investigation of different S-shaped intermediate turbine ducts

The Effects of Incoming Vortex and Wake on the Aerodynamics of an Intermediate Turbine Duct

Experimental and Numerical Investigation of the Non-Reacting Flow in a High-Fidelity Heavy-Duty Gas Turbine DLN Combustor

Numerical Investigation on Ultra-High-lift Low-Pressure Turbine Cascade Aerodynamics at Low Reynolds Numbers Using Transition-Based Turbulence Models

Aerodynamic Characteristics of Different Airfoils under Varied Turbulence Intensities at Low Reynolds Numbers

Numerical research on the aerodynamic performance of inlet volute duct for a heavy-duty gas turbine

Fast Multi-Objective Optimization Design of Gas Turbine L-inlet Duct

The Effect of Fsti to the Combined Separation Control Strategy of Surface Roughness with Upstream Wakes

Streamwise vortex transportation and loss generation in an intermediate turbine duct

Aerodynamic study of a bifurcated turboprop engine inlet with a propeller for flow at ground suction conditions

Effect of Unsteady Fan-Intake Interaction on Short Intake Design

Numerical Study on Unsteady Flow of a Supersonic Partial Admission Impulse Turbine

Direct Numerical Simulation on the Unsteady Flow Field of Low-Pressure Turbine Cascades With and Without Upstream Wake at Low Reynolds Number

A novel preliminary design method for intermediate compressor/turbine ducts

DIRECT NUMERICAL SIMULATION OF AN HPT STAGE: UNSTEADY BOUNDARY LAYER TRANSITION AND THE RESULTING FLOW STRUCTURES

Numerical Analysis on Effects of Inlet Pressure and Temperature Non-Uniformities on Aero-Thermal Performance of a HP Turbine

Simulation Of Transitional Flow On Low Pressure Turbine Blade With Unsteady Downstream Potential Interaction

Numerical Study on Meridional Passage Contour of Casing in an Inter-turbine Duct

Effects of Periodic Incoming Wakes on the Aerodynamics of a High-Speed Low-Pressure Turbine Cascade