Abstract:Concrete structure is usually affected by sulfate and magnesium salt in soil water environmental. In order to explore anti-erosion properties of cement concrete and high-performance concrete mixed with slag powder after immersed in solution with sulfate and magnesium salt, the study designed three water-binder ratio treatments and two slag powder content treatments. After mixing with water, 1050 specimens (10 mm×10 mm×60 mm) were prepared and incubated in conditions of 20℃ and moisture≥9.5% for 28 d. Then, they were immersed in five different solutions with different sulfate and magnesium concentrations for determine anti-erosion coefficient and microstructure of the specimens during erosion. The results showed that: The cement had many pores with large pore size when water-binder ratio was 0.50, and the maximum diameter of pore reached 372.5μm. The improvement of the pore structure was not obvious when the water-binder ratio decreased to 0.35. When the pure cement concrete specimens was immersed in solution with 2500 mg/L SO42- and 1400 mg/L magnesium2+ for 4 months. The pores of specimens were full of hydration products such as CaSO4·2H2O, 3CaO·Al2O3·3CaSO4·32H2O (AFt), and a small amount of Mg(OH)2 and MgO?SiO2?H2O, which could lead to cracks in concrete, peeling off the side parts, even being crisp and surface slurry loss seriously. After 2 months, the erosion coefficient showed a downward trend with erosion duration and was below 0.85, indicating a limited anti-erosion capacity of silicon concrete. When the concrete was added with slag powder, the pore numbers became small and pore size was small. The largest pore size of concrete with water-binder ratio of 0.35 and 0.30 was only 1/7 and 1/8 times as that of concrete with water-binder ratio of 0.50. Meanwhile, the content of Ca(OH)2 was reduced. The concrete structure became loose, which was more obvious for specimens with low water-binder ratio. After 12 months of erosion in solution of sulfate and magnesium salt (20250mg/L SO42-and 2800mg/L Mg2+), the edge of specimen did not have erosion products and crystals of MgSO4·7H2O, Na2SO4·10H2O, Mg2(OH)3Cl·4H2O, and the corrosion resistance coefficient was still more than 0.85. It suggested that slag powder can significantly improve the anti-erosion properties of high performance concrete formulated by 32.5 silicate cement. Therefore, when cements were used for environment with solutions including 13000 mg/L SO42- and 1400 mg/L Mg2+, or 20250 mg/L SO42- and 2800 mg/L Mg2+, the water-binder ratio of concrete should not be greater than 0.35 and 0.30, respectively, while slag powder content was appropriate from 40% to 45%.The study could provide data support and theoretical basis for concrete preparation and application in irrigation engineering (dam foundation, gates infrastructure and channels etc.) and greenhouse concrete foundation engineering.

Experimental study on concrete deterioration caused by Limnoperna fortunei fouling

Effect of chloride penetration on CFRP sheet, CFRP‐concrete interface, and CFRP‐strengthened concrete beams

Performance tests on anti-fouling and anti-corrosion of coating materials

Influence mechanisms under different immersion methods and different strengths of concrete in corrosive environments, and verification via long-term field test

Effecting Coefficients for Concrete Structure Durability Design Index

Concrete Deterioration Caused by Freshwater Mussel Limnoperna Fortunei Fouling

EFFECT OF REINFORCEMENT AND CORROSION ON DAMPING CAPACITY OF CONCRETE MEMBERS

Study on the Mechanical Properties and Microstructure of Fiber-Reinforced Concrete Subjected to Sulfate Erosion

Effects of controlled permeability formwork on surface properties and early age shrinkage of concrete

Study on Relation Between Early-age Performance of Concrete and Its Durability

Research on the performance evolution of concrete under the coupling effects of sulfate attack and carbonation

Microstructure characteristics of concrete after erosion of magnesium salts and sulfates

Experimental Evaluation of the Concrete Damage and Pore Characteristics under Salt-Freezing Cycles

Experimental study of the deterioration mechanism of concrete under sulfate attack in wet-dry cycles

A Research on Durability Degradation of Mineral Admixture Concrete

Study on the Deterioration of Concrete under Dry-Wet Cycle and Sulfate Attack

Research on Performance Deterioration of Multi-Walled Carbon Nanotube–Lithium Slag Concrete under the Coupling Effect of Sulfate Attack and Dry–Wet Cycles

Combined effect of abrasion of sediment-laden flow and chloride ions penetration on the durability of concrete

The Effect of Acid Rain on Strength and Corrosion Performance of Slurry Infiltrated Fiber Concrete

Relationship Between Microscopic Pore Structure and Strength of Cement-Based Materials with Low Water-Binder Ratio Under Sulfate Attack Environment

Effect of dry–wet ratio on pore-structure characteristics of fly ash concrete under sulfate attack