Abstract:According to the International Electrotechnical Commission, medium voltage ranges from 1 kV to 36 kV. In this voltage range, the field of power electronics has been focusing on developing power converters with high efficiency. Converters for such applications include solid-state transformers, energy storage systems for vehicle charging, electric aircraft, etc. Power ranges could reach tens to hundreds of kilowatts at relatively high frequency (10–50 kHz). Currently, there are no high-frequency power semiconductors capable of switching these voltage levels. Instead of using a single power switch, a string of power switches is used. The upper switches in the string require special attention because they need the highest isolation capabilities and a floating control signal and power supply for the gate driver. Many techniques have been proposed to accomplish this, but they commonly use separate circuits for the control signal and the power supply, increasing the cost, size, and complexity of the gate driver. This paper presents a gate driver for medium voltage with high-voltage isolation capabilities in a single structure for the control signal and the power supply. The proposed gate driver uses a resonant converter that transmits power within the gate driver information. A demodulator separates the gate driver information from the power signal, obtaining the power supply and the control signal for the switch. The paper includes simulation and experimental results that demonstrate the viability of the proposal. The experimental results show the principal features of the gate driver, achieving improvements in complexity, isolation capabilities, and both rise and fall times for large input capacitances of power semiconductor switches. The proposed gate driver presents a rise time of 44 ns and a fall time of 46 ns for the gate input capacitance of currently available SiC MOSFETs. The isolation barrier uses a 25 mm air gap, achieving an isolation capability of approximately 68.2 kV, which exceeds the requirements for MV applications.

A 0.18 μ m high-voltage area efficient integrated gate driver for piston engine fuel injection control SoC

Fully Integrated High-Voltage Level Shifts and Drivers for Buck Converters.

A New Hybrid Gate Drive Scheme for High Frequency Buck Voltage Regulators

A 2–10 MHz GaN HEMTs Half-Bridge Driver with Bandgap Reference Comparator Clamping and Dual Level Shifters for Automotive Applications

A Tri-Slope Gate Driving GaN DC–DC Converter with Spurious Noise Compression and Ringing Suppression for Automotive Applications

High-voltage LED Driver Based on SOI Process

A Synchronous Boost Converter with High Speed and High Accuracy Peak Current Control Unit.

25.2 A 10mhz 3-to-40v VIN Tri-Slope Gate Driving GaN DC-DC Converter with 40.5dbµv Spurious Noise Compression and 79.3% Ringing Suppression for Automotive Applications

A 1-Mhz High-Efficiency 12-V Buck Voltage Regulator with a New Current-Source Gate Driver

A regulated charge pump with wide current driving capability for low-voltage applications

High-voltage Integrated Circuit Technology for Plasma Display Panel Drivers

A Novel Gate Control Strategy for 3.4kv Cascade Sic Mosfets Stack

A Fuel Injection Control Soc For Diesel Engine Management System

An Active Gate Driver Design to Reduce Voltage and Current Overshoots for SiC MOSFET Modules

A Novel Single Isolation Channel Gate Driver with Bi-Directional-Signal and Forward-Power Transmission

A 20mhz 4A Gate Driver with 5.5 to 24V Output Drive Voltage for Wide Bandgap FETs.

Novel Low-Side/High-Side Gate Drive and Supply With Minimum Footprint, High Power Density, and Low Cost for Silicon and Wide-Bandgap Transistors

A 400-V Half Bridge Gate Driver for Normally-off GaN HEMTs with Effective dv/dt Control and High dv/dt Immunity

An Active Gate Driver for Suppressing the Current Oscillation of SiC MOSFET

A 20-V Pulse Driver Based on All-nMOS Charge Pump Without Reversion Loss and Overstress in 65-nm Standard CMOS Technology

Isolated Gate Driver for Medium Voltage Applications Using a Single Structure