Abstract:The rheological properties of warm-mix recycled asphalt binders are critical to enhancing design quality and interpreting the performance mechanisms of the corresponding mixtures. This study investigated the rheological behavior of warm-mix recycled asphalt binders with high percentages of RAP binder. The effects of two warm-mix additives [wax-based Sasobit (S) and surfactant-based Evotherm-M1 (E)], a rejuvenating aging [ZGSB (Z)], four RAP binder contents (0%, 30%, 50% and 70%), and three aging states (unaged, short-term aged and long-term aged) were evaluated in detail using the dynamic shear rheometer (DSR), bending beam rheometer (BBR) and Brookfield rotational viscometer tests as well as conventional performance tests over the whole range of temperatures. The results showed that the rejuvenating agent Z effectively alleviated the aging effect of the RAP binder; however, it could hardly eliminate entirely this negative impact, especially at higher RAP binder contents. The addition of S remarkably lowered the apparent viscosity of the warm-mix recycled binders by up to 35.0%, whereas E had little influence on the binder viscosity due to its surfactant nature. Besides, S performed much better in improving rutting resistance (with the increase of up to 411.3% in |G*|/sinδ) than E, while E exhibited superior fatigue performance (with the reduction of up to 42.3% in |G*|·sinδ) to that of S. In terms of the thermal cracking resistance, E had very slight influence and S even yielded an adverse impact (with the increase of up to 70.2% in Sa and the decrease of up to 34.1% in m-value). Further, S broadened the ranges of pavement service temperatures by about 12 °C, whereas E almost did not change the PG grades of the binders. Finally, regarding the characteristics of viscoelastic master curves, S considerably improved the dynamic modulus and lowered the phase angle of the binders over a wide range of frequencies and temperatures but led to the failure of the time-temperature superposition principle due to its thermorheologically complex nature. Nevertheless, in this regard, the effect of E was found very mild.

Exploring the recovery capacity of recycling agents on atomic-scale energy properties of aged bitumen and their potential correlations with high-temperature rheological performance

Role of thermodynamic relaxation on effectiveness of recycling agents on properties of aged bitumen

Evaluation of Rheological and Aging Behavior of Modified Asphalt Based on Activation Energy of Viscous Flow

A New Short-Term Aging Model for Asphalt Binders Based on Rheological Activation Energy

A molecular dynamics simulation study on the recovery performance of aged asphalt binder by waste vegetable oil rejuvenators

Characterisation of bitumen through multiple ageing-rejuvenation cycles

Laboratory Performance Evaluation on the Recovering of Aged Bitumen With Vegetable Oil Rejuvenator

Rheological Characterization of Reversibility Between Aging and Rejuvenation of Common Modified Asphalt Binders

Laboratory study of the effect of oil-based recycling agents on high RAP asphalt mixtures

Linear viscoelastic, viscoplastic, and damage characterization of recycled asphalt binders and mixtures containing recycling agents with long-term aging

Workability and Rheological Property Evolution of Active Rejuvenated Styrene–Butadiene–Styrene-Modified Bitumen in the Early Stage

Regeneration Effect of a New Bio-Based Warm-Mix Rejuvenator on Performance and Micro-Morphology of Aged Asphalt

Molecular Dynamics Simulation and Experimental Validation on the Interfacial Diffusion Behaviors of Rejuvenators in Aged Bitumen

Reversibility of Macroperformance of Virgin Asphalt Binder at Various Aging-Regeneration Stages Based on Rheology

Investigation into Rheological Behavior of Warm-Mix Recycled Asphalt Binders with High Percentages of RAP Binder

Effects of rejuvenators and aging conditions on the properties of blended bitumen and the cracking behavior of hot asphalt mixtures with a high RAP content

Use of Hansen Solubility Parameters (HSP) in the selection of highly effective rejuvenators for aged bitumen

Rejuvenating effect of soft bitumen, liquid surfactant, and bio-rejuvenator on artificial aged asphalt

Characterisation of rejuvenation of various modified asphalt binders based on simplified chromatographic techniques

Effect of reclaimed bio-oil and waste crumb rubber on bitumen viscoelasticity

Determination of Rejuvenator Proportion within the Recycled Bitumen: Empirical Double-Logarithmic Formula and Calibration