Abstract:Direct numerical simulations (DNS) of an upward heated pipe flow of supercritical CO2 (at Re0=3600) were carried out with and without conjugate heat transfer (CHT). The aim is to identify the impact of CHT on this specific flow problem and provide information for relevant numerical studies. The configuration is referred to one of the experiments carried out by Luo (2014), with a stainless steel (SS 304) pipe and a thermal activity ratio of 0.061. When CHT is introduced, the predictions of heat transfer coefficient (HTC) and wall temperature obtained in DNS are slightly improved against the experiment measurements. Two primary factors arise when CHT is considered, which are the axial redistribution of wall heat flux and the damping of the enthalpy fluctuations. The former affects the heat transfer particularly within a short distance after the inlet, leading to a more rapid establishment of the thermal boundary layer and a more rapidly progressing ‘laminarising’ process. The latter introduces substantial differences in the fluctuations of enthalpy (∼30 times difference) and density (∼40 times difference), which is however confined within a small region close to the wall and diminishes rapidly further away, resulting in a minor effect on turbulence and heat transfer in the main flow. When CHT is omitted, turbulent kinetic energy is over-predicted up to 1.55 times at most, in particular when the flow is being ‘laminarised’ (z/D<30). This is attributed to the discrepancies in shear production rather than the buoyancy production of the turbulent kinetic energy. Additionally, CHT alters both the laminar (Nul) and turbulent contributions (Nut) to the Nusselt number, with Nul starting at a lower level close to the inlet and the peak of Nut being reduced by 12.3%. These findings provide an insight on the impact of CHT on turbulence and heat transfer at different stages and valuable information for a more accurate modelling method for supercritical fluid flows.

Experimental and numerical investigation on the mechanisms of novel heat transfer deterioration of supercritical CO 2 in vertical tubes

Experimental study on heat transfer deterioration of supercritical CO2 in a round tube:A boundary assessment

The characteristics and mechanisms of self-excited oscillation pulsating flow on heat transfer deterioration of supercritical CO2 heated in vertical upward tube

Investigation of Buoyancy-Enhanced Heat Transfer of Supercritical CO2 in Upward and Downward Tube Flows

Experimental investigation and theoretical analysis on the heat transfer deterioration of supercritical CO2 in mixed and forced convection in vertical-straight tube with downward flow

Investigation of Flow Boiling Heat Transfer Characteristics of CO2in Horizontal Mini-Tube

Numerical Investigation on Turbulent Heat Transfer of Supercritical CO2 in a Helically Coiled Tube

The influence of tube diameter parameters on the flow resistance and heat transfer characteristics of supercritical CO 2 in horizontal tubes

Impact of Conjugate Heat Transfer on the Turbulence and Heat Transfer in an Upward Heated Pipe Flow at Supercritical Pressure

Investigation And Modeling Of The In-Tube Heat Transfer Of Fluids At Supercritical Pressure During Heating

An expansion effect based pseudo-boiling critical point model for supercritical CO<sub<2</sub<

Flow and Heat Transfer Instability of Supercritical Carbon Dioxide in a Vertical Heated Tube

Numerical study on the heat transfer deterioration of supercritical CO 2 in straight tubes under different inclination angle

Numerical Investigation of Heat Transfer Characteristics of scCO2 Flowing in a Vertically-Upward Tube with High Mass Flux

Numerical Investigation of Supercritical Water Turbulent Flow and Heat Transfer Characteristics in Vertical Helical Tubes

Study of Heat Transfer for Co2 Flow Boiling in Horizontal Small Diameter Tubes

Numerical Study on the Heat Transfer Deterioration and Its Mitigations for Supercritical CO2 Flowing in a Horizontal Miniature Tube

Direct Numerical Simulation of Convective Heat Transfer of Supercritical Pressure in a Vertical Tube with Buoyancy and Thermal Acceleration Effects

Deterioration and Instability of Heat Transfer to H2O/CO2 Mixtures in Near-Critical Region for Horizontal Flow

Numerical study on flow and heat transfer of S−CO2 in inclined tubes under different flow conditions

Heat Transfer Characteristics of CO2 in a Horizontal Tube under Subcritical and Supercritical Pressures