Abstract:The given paper is aimed at introducing our experimental study over the effect of the relief duct on the ventilation of the gas explosion in a spherical vessel. We have implemented the experiment by using a premixed methane-air mixture([φ(CH4) = 10%]without special instructions) to analyze the effects of the relief duct length,the vessel volume,the ignition position,the gas volume fraction and the membrane rupture pressure on the duct-venting explosion. The results of our experiment show that those parameters have significant effect on the process of the duct-vented explosion. In addition,both the positive pressure and negative pressure in the spherical vessel tend to increase with the increase of the length of the relief duct,whereas in the case of the closed explosion in the isolated spherical vessel,the vessel volume has hardly no effect on the peak pressure of gas explosion,for the gas explosion in the big vessel and the small vessel vented through the same relief duct(the duct length is 6 m and the diameter is 0. 06 m),though the peak pressure in the big vessel can be made as high as 3. 3 times as much as the peak pressure in the small vessel. Therefore,as compared with the closed explosion in the big isolated vessel,for the duct-vented explosion,the rate of pressure rise in the big vessel can be significantly higher because for the duct-vented explosion,compared to central ignition,the peak pressure in the vessel for rear ignition is higher; the relief duct results in that peak pressure in the vessel can be made much higher than that for the simply vented explosion(without relief duct). Therefore,considering the maximum reduced pressure,the duct-vented explosion,or simply the vented explosion,though the peak pressures in the vessel may increase with the increase of membrane rupture pressure,the difference can be gradually made smaller with the increase of the membrane rupture pressure,thus implying that the effect of the duct tends towards the mitigation. What is more,since the presence of the relief duct always tends to reduce the efficiency of the ventilation and increase the severity of the explosion,the effect of the presence of relief duct on venting process should be taken into full account and the compressive strength of the vessel itself should be improved even earlier than when they were at the moment the vessel was under design.

Investigation of the length-to-diameter ratio of ducts effect on the oscillation propagation behavior and vented characteristics for propane-air vented explosions

Influence of Side Duct Position and Venting Position on the Explosion and Combustion Characteristics of Premixed Methane/Air

Effects of vent layout and vent area on dynamic characteristics of premixed methane-air explosion in a tube with two side-vented ducts

Effect of dimensionless vent ratio on the flame-shock wave evolution dynamics of blended LPG/DME gas explosion venting

Flame characteristics of premixed H2-air mixtures explosion venting in a spherical container through a duct

Influence of vent duct bend angle on inner dust explosion

Evaluation of unrestricted hydrogen and hydrogen-methane explosion venting through duct

Insight into vented explosion mechanism and premixed flame dynamics in linked vessels: Influence of membrane thickness and blocking rate

Study on Explosion Venting Characteristics of L-Type Venting Duct

Duct-vented explosion of stoichiometric hydrogen/methane/air mixtures at various hydrogen ratios

Experimental investigation on the effect of vent film material and thickness and hydrogen fraction on explosion-venting features of H2/CO/Air mixtures within a horizontal duct

Research on the effects of coal dust parameters on the venting characteristics of gas/dust two-phase explosions

Experimental study on the flame-dual field overpressure coupling evolution characteristics of LPG/DME blended gas explosion venting

Effects of methane volume fractions and vent areas on dynamic characteristics of vented methane-air explosion in a half-open duct

Investigation on the Flame and Pressure Behaviors of Vented Hydrogen-Air Deflagration from a Duct-Connected Vessel: Effects of Venting Diameter and Static Activation Pressure

Study on the Influence of Vent Shape and Blockage Ratio on the Premixed Gas Explosion in the Chamber with a Small Aspect Ratio.

The overpressure and temperature characteristics of hydrogen-air mixtures during a vented explosion in a large L/D ratio duct: Effect of burst pressure

Experimental study over the effect of the relief duct on the venting of gas explosion in a spherical vessel

Investigation on the characteristics of vented stoichiometric methane-air explosion: Effect of ignition positions and obstacles

Investigation on vented ethanol-gasoline vapor explosion characteristics initiated via single and dual sparks

Experimental research on the venting characteristics of methane and coal dust two-phase system mixture explosions