Abstract:Coagulation plays an important role in effectively alleviating ultrafiltration (UF) membrane fouling due to the existence of flocs. In comparison to traditional filtration, direct filtration (no sedimentation tank) is generally considered to result in less membrane fouling due to the looser cake layer formed on the membrane surface. However, cake layer characteristics are easily influenced by operating conditions (e.g., sedimentation time, temperature), resulting in different fouling loads and the still very limited knowledge about the fouling behavior. Here, a detailed investigation of UF membrane performance was carried out to analyze the differences between traditional filtration and direct filtration. The results showed that a critical settling time indeed existed when flocs gradually settled, leading to severe membrane fouling induced by a dense and thick cake layer. Therefore, the traditional filtration performed worse when the settling time was shorter than the critical time, while it performed better when the settling time was longer. In comparison to room temperature water, the proportion of membrane fouling caused by the cake layer increased at low water temperature due to the contracted membrane pore size, and the cake layer thickness became the main fouling load. The longer the settling time, the fewer pollutants reached the membrane surface, the thinner the cake layer, and the lower the potential for membrane fouling. Thus, traditional filtration performed better than direct filtration, and the critical settling time was not obvious. Although solution pH played an important role in floc properties, the fouling load was influenced little and traditional filtration still performed better. This work shows that the cake layer properties/fouling loads vary with the settling time during the coagulation-UF process, and this finding is of great significance to the improvement of membrane technology in drinking water plants.

Membrane Fouling in Ultrafiltration of Natural Water after Pretreatment to Different Extents

Characterization of Fouling in Immersed Polyvinylidene Fluoride Hollow Fibre Membrane Ultrafiltration by Particles and Natural Organic Matter

Identification of the Fouling-Caused Foulants with Different Pretreatments During Ultrafiltration in Polluted Raw Water

A Comparison of Organic Matters Responsible for Immersed Ultrafiltration Membranes Fouling in Drinking Water Treatment

Understanding Pvdf Ultrafiltration Membrane Fouling Behaviour Through Model Solutions and Secondary Wastewater Effluent

Application of UV/chlorine pretreatment for controlling ultrafiltration (UF) membrane fouling caused by different natural organic fractions

Analysis of the major particle-size based foulants responsible for ultrafiltration membrane fouling in polluted raw water

Effect of Sludge Retention on UF Membrane Fouling: the Significance of Sludge Crystallization and EPS Increase.

Performance of an integrated granular media – Ultrafiltration membrane process for drinking water treatment

Characterization of Dissolved Organic Matter and Membrane Fouling in Coagulation-Ultrafiltration Process Treating Micro-Polluted Surface Water

Influence and mechanism of different molecular weight organic molecules in natural water on ultrafiltration membrane fouling reversibility

An autopsy study of hollow fiber and multibore ultrafiltration membranes from a pilot-scale ultra high-recovery filtration system for surface water treatment

Fluorescent Natural Organic Matter Responsible for Ultrafiltration Membrane Fouling: Fate, Contributions and Fouling Mechanisms

Effects of Coagulation on Submerged Ultrafiltration Membrane Fouling Caused by Particles and Natural Organic Matter (NOM)

Influence of Sedimentation with Pre-Coagulation on Ultrafiltration Membrane Fouling Performance.

Membrane fouling during ultrafiltration (UF) of surface water: Effects of sludge discharge interval (SDI)

Effect of Filtration Mode and Backwash Water on Hydraulically Irreversible Fouling of Ultrafiltration Membrane

Coupling Continuous Sand Filtration to Ultrafiltration for Drinking Water Treatment: Improved Performance and Membrane Fouling Control

[Membrane fouling by secondary effluent of urban sewage and the membrane properties].

Coagulation-ultrafiltration Integrated Process for Membrane Fouling Control: Influence of Al Species and SUVA Values of Water

Effect of Intermittent Ultrasound on Controlling Membrane Fouling with Coagulation Pre-Treatment: Significance of the Nature of Adsorbed Organic Matter