Emission and Catalytic Conversion Features of the EFI Engine Fueled with Ethanol/gasoline Blends
Dong-hui QI,Sheng-hua LIU,Hui LI,Sheng-chun LV
DOI: https://doi.org/10.3969/j.issn.1009-6094.2006.05.007
2006-01-01
Abstract:The present paper aims at introducing the authors' experimental investigation over the pollutant emissions and catalytic conversion efficiency features of the synthetic electronic fuel injection(EFI)gasoline engine fueled with ethanol-gasoline blends at various blending ratios(0 vol %,10 vol %,20 vol %).In our investigation,ethanol was treated as a partially oxidized hydrocarbon and then added to the blended fuel,which gives out more oxygen in the combustion process and leads to the so-called “leaning effect.When used,the fuel injection ratio was adjusted by means of a closed-loop,in which the on-board ECU controlled the fuel injection with feedback signal from the built-in oxygen sensor in a exhaust pipe.By control the closed-loop,it is possible to measure the effect of the ethanol added to the pollutant emission and the catalytic conversion efficiency features.The results of our investigation indicated that the ethanol-gasoline blends as a kind of improved fuel,with ethanol content increased in the blends,helps to remarkable decreasing the engine-out CO emission.The improved level proved to be as high as up to 15%.Whereas the engine-out HC emissions slightly increase at the high engine load,the engine-out NO_x emission depends on the operating condition of the engine rather than that of the ethanol content.Furthermore,the effect of the ethanol on catalytic conversion efficiency proves to be related to the engine speed,load as well as air fuel ratio.And,finally,the acetaldehydes emissions of the engine with new blends,measured by gas chromatography,prove evidently higher than that of the gasoline engine.However,the unburned ethanol emissions of the blends engine prove slightly higher than that of gasoline engine,while the methanol emissions of the blends engine are almost similar to that of the gasoline one,but the pollutants can be decreased to approximately zero value after the three-way catalytic converter.While idling,the CO,HC and NO_x emissions proves to be slightly decreased.