Abstract:In order to study the mechanism of biomass tar formation and elimination in a two-stage downdraft gasifier, the nascent rice straw pyrolysis tar evolution properties under homogeneous/heterogeneous decomposition conditions have been investigated in a constructed lab-scale two-stage reactor by varying factors as temperature, concentration and reforming agents of CO(2)/H(2)O/O(2), and char bed heights. The nascent tar was produced in the first stage reactor and then decomposed in the second stage with different reforming agents or char beds. In the first stage, the results showed that nascent pyrolysis tar yields increased with increasing pyrolysis temperature, tar was mainly produced during 200-400 degrees C, and 400-500 degrees C would be a proper pyrolysis temperature range in commercial operation due to little effect on tar yields in higher temperature. In the second stage, it can be observed that nascent biomass tar was converted into polycyclic aromatic hydrocarbons (PAHs) (even soot), thermally stable one ring aromatics, and noncondensable gases in homogeneous conditions with increasing temperature. Different effects were obtained in varying tar species under different homogeneous reforming agents. However, benzene, toluene, styrene, phenol, and naphthalene are the most typical compounds, accounting for 50-75% in total tar concentration at 900 degrees C in all decomposition conditions. Char bed can selectively reduce PAH species remarkably and increase the toluene yields. As for the three reforming agents, steam showed the highest efficiency in tar elimination, while CO(2) and O(2) present will induce OH, H, and O radicals formation, which increases hydrocarbon conversion. The mechanism of tar destruction in a two-stage downdraft gasifier can be concluded as follows: nascent tar yields from the pyrolysis stage will be first reformed into PAHs, thermally stable one ring aromatics and noncondensable gases in the throat region, and then PAHs species are almost completely decomposed by the char bed, which are the main troublesome tar components in syngas, and finally the syngas with low tar was obtained.

Tar Formation During Co-Gasification of Biomass and Coal under Different Gasification Condition

Tar Formation in Pressurized Fluidized Bed Air Gasification of Woody Biomass

Effects of Steam and CO2 on Gasification Tar Composition and Evolution of Aromatic Compounds.

Evolving characteristics of tar during biomass fluidized bed gasification

Production of Tar during the Process of Biomass Gasification

Steam Co-Gasification of Biomass and Coal in Decoupled Reactors

Effect of Steam on the Tar Reforming during Circulating Fluidized Bed Char Gasification

Heterogeneous Cracking Reaction of Tar over Biomass Char, Using Naphthalene As Model Biomass Tar

Experimental Study on Influence of Operating Parameters on Tar Components from Corn Straw Gasification in Fluidized Bed

Effects of Alkali and Alkaline-Earth Metals and Retention Time on the Generation of Tar During Coal Pyrolysis in a Horizontal Fixed-Bed Reactor

Gas Upgrading in a Downdraft Fixed-Bed Reactor Downstream of a Fluidized-Bed Coal Pyrolyzer

Experimental Study on Coal Partial Gasification Coproducing Char, Tar, and Gas

Nascent Biomass Tar Evolution Properties under Homogeneous/Heterogeneous Decomposition Conditions in a Two-Stage Reactor

Characterization of tar formation during high temperature gasification of different chemical compositions in biomass

Experimental Investigation on Tar Formation and Destruction in A Lab-Scale Two-Stage Reactor

Experimental Investigation of Biomass Gasification in a Fluidized Bed Reactor

Effect of temperature and gasification gas from char on the reactions of volatiles generated from rapid pyrolysis of a low rank coal

Catalytic conversion characteristics of tar at different temperatures during circulating fluidized bed gasification

Integrated Process of Coal Fast Pyrolysis in a Fluidized Bed Reactor with Reforming Reaction of Simulated Fuel Gas to Promote Light Tar Evolution

Experimental Study on Catalytic and Thermal Cracking of Tar from Biomass Pyrolysis

Characterization of Tar from Sawdust Gasified in the Pressurized Fluidized Bed