Abstract:Grouting is a common method to improve the mechanical properties of the fractured rock mass. Understanding the effect of grouting on the mechanical properties of fractured rock mass is considered essential for the establishment of efficient grouting designs and the development of new grouting materials. Therefore, in this research, a series of experiments are conducted to reveal the influence of grouting material on the mesostructure and macroscopic mechanical behavior of the grout-rock interface. Firstly, grouted samples with different grouting materials (ordinary Portland cement (OPC), microfine cement (MFC), and epoxy resin (EPR)) were prepared. Then, nuclear magnetic resonance (NMR) and X-ray computed tomography (CT) were carried out on the grouted rock mass to investigate the pore phase composition and mesostructure. Subsequently, correlating acoustic emission (AE) counts and shear stress-displacement curves reveal the shear failure process of the grouted rock mass. Finally, the failure mechanism of grouted rock mass was discussed in detail. The results displayed that the damage characteristic during shear failure of the grouted rock mass may be inferred from the AE counts. The shear strength of the sample grouted with OPC, MFC, and EPR is 8.3%, 41.5%, and 142.8% of that of intact rock, respectively. EPR reduces the pore content at the grout-rock interface compared with cement-based grout, especially the macropores and the micropores. Compared with the rock layer, the number of pores at the grout-rock interface of the sample grouted with OPC, MFC, and EPR is reduced by 43.3%, 57.1%, and 64.3%, respectively. The hydrophilicity of the rock leads to a discrepancy in the hydration degree of cement-based grout, which causes uneven shrinkage of the grout and produces cracks. However, as a chemical grouting material, EPR may permeate into the rock interior and modify the mesostructure of the grout-rock interface. The grout-rock bonding and mesostructure of the grout-rock interface dominate the failure mechanism, thus determining the macroscale mechanical properties of the grouted rock mass.

Experimental and Numerical Studies on Nondestructive Evaluation of Grout Quality in Tendon Ducts Using Impact-Echo Method

Numerical Modeling of Grouted Connection Damage Development under Uniaxial Loading

Experimental study of the direct shear characteristics of cement grout under constant normal loading and stiffness boundary conditions

Impact-echo Characteristic Frequencies Response to Grouting Fullness in Ducts of Prestressed Box Beam and Application

Influencing factors on impact-echo characteristic frequency in a box beam

Sedimentation-affected Engineering Performances and Microstructures of a Hybrid Portland- Sulfate Aluminate Cement Grout Cast in Long Tubes

Experimental Research and Numerical Simulation on Grouting Quality of Shield Tunnel Based on Impact Echo Method

Improving the Accuracy of Impact‐Echo in Testing Post‐Tensioning Ducts

Experimental and Numerical Investigation of Cyclic Grouting Compactness in Prestressed Tendon Ducts

Study of grouting effectiveness based on shear strength evaluation with experimental and numerical approaches

Defect detection of grouting sleeve connection with energy ratio change in frequency domain

Tunnelling-induced ground deformation subjected to the behavior of tail grouting materials

The Performance Analysis of Grouting Repair Effect on the Accuracy of Disturbance Stress Test in Damaged Surrounding Rock Mass

Detection of sleeve grouting connection defects in fabricated structural joints based on ultrasonic guided waves

Study of Grouting Reinforcement Mechanism in Fractured Rock Mass and Its Engineering Application

Characterization of Damage Progress in the Defective Grouted Sleeve Connection Using Combined Acoustic Emission and Ultrasonics

Experimental-numerical investigation on grout diffusion and washout in rough rock fractures under flowing water

Experimental investigation on the failure mechanism of grouted rock mass: Mesostructure and macroscopic mechanical behavior

Study on the strength influence mechanism and cracking mechanism of stone powder-cement floor grouting materials

Experimental and Numerical Study of Grout Effectiveness and Force-Transfer Mechanism in Socket Connections

An extended discontinuous deformation analysis (DDA) for simulation of grouting reinforcement in a water-rich fractured rock tunnel