Abstract:High cost of microalgal biofuel is caused by all the steps in current technology, including cultivation, harvesting, lipid extraction, biofuel processing and wastewater and waste treatment. This study aims to systematically reduce these costs with one integrated process, in which carbonate is used for cell rupture, lipid extraction and biodiesel processing, and then recycled for CO2 absorption and carbon supply for a new round of algae cultivation. To reach this goal, carbonate-heating treatment with N, N'-dibutylurea which can enhance cell disruption were used for cell-wall breaking of wet Neochloris oleoabundans (UTEX 1185) biomass. Lipid extraction was fulfilled with carbonate/ethanol aqueous two phase extraction method and residual carbonate with wastewater from bottom phase was recycled to absorb CO2 to generate bicarbonate for algal cultivation with fresh medium. Taking into comprehensive consideration of cell disruption efficiency, partition coefficient, and lipid recovery, the condition of cell disruption and lipid extraction was set at 90 degrees C, 100 min reaction time, 1:7.5 DBU:H2O (w/w) ratio, 1:3 Na2CO3:H2O (w/w) ratio, and 9% (w/wT) ethanol concentration. The results showed that carbonate-heating treatment of wet N. oleoabundans biomass resulted in up to 90.7% cell disruption efficiency. The lipid recovery rate in carbonate/ethanol system was up to 97.9%, and the final biodiesel production was 1.30 times of that with Soxhlet method. Utilization of the waste broth after CO2 absorption with the content of 4% (v/vT) in the medium for new batch of algae cultivation resulted in biomass concentration of 1.68 g/L. The corresponding total fatty acids production was 0.35 g/L, which was 1.63 fold of that with fresh medium. This study firstly proved the feasibility of using carbonate for lipid extraction and biodiesel production and recycle waste carbonate for carbon re-supply during algae cultivation. (C) 2021 Elsevier B.V. All rights reserved.

The Capacity of Bicarbonate Capture of a Continuous Microalgae Photo-bioreactor System

Study on Medium Composition of Microalgae Optimization for CO2 Removal from Air by A Membrane-Photobioreactor

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

Carbon dioxide removal from air by microalgae cultured in a membrane-photobioreactor

Enhanced inorganic carbon uptake by Chlorella sp. IMMTCC-2 under autotrophic conditions for lipid production and CO2 sequestration

Microfluidic Chemostatic Bioreactor for High-Throughput Screening and Sustainable Co-Harvesting of Biomass and Biodiesel in Microalgae

Comparison of Scenedesmus obliquus in CO2 Capture, Biolipid Production and Nutrient Removal

A novel concept of bicarbonate-carbon utilization via an absorption-microalgae hybrid process assisted with nutrient recycling from soybean wastewater

Biomass Producing and CO2 Capturing Simultaneously by Chlorella Vulgaris: Effect of CO2 Concentration and Aeration Rate

Carbonate Assisted Lipid Extraction and Biodiesel Production from Wet Microalgal Biomass and Recycling Waste Carbonate for CO2 Supply in Microalgae Cultivation.

Bicarbonate-based Integrated Carbon Capture and Algae Production System with alkalihalophilic cyanobacterium

Selection of Microalgae and Cyanobacteria Strains for Bicarbonate-Based Integrated Carbon Capture and Algae Production System

Simultaneous CO2 and biogas slurry treatment using a newly isolated microalga with high CO2 tolerance

Integration of CO2 absorption with biological transformation via using rich ammonia solution as a nutrient source for microalgae cultivation

Intensification of Brewery Wastewater Purification Integrated with CO2 Fixation Via Microalgae Co-Cultivation

Simultaneous CO 2 and biogas slurry treatment using a newly isolated microalga with high CO 2 tolerance

Microalgae carbon fixation integrated with organic matters recycling from soybean wastewater: Effect of pH on the performance of hybrid system

Physiological and Biochemical Responses of Bicarbonate Supplementation on Biomass and Lipid Content of Green Algae Scenedesmus sp. BHU1 Isolated From Wastewater for Renewable Biofuel Feedstock

Sustainable Carbon Capture Via Halophilic And Alkaliphilic Cyanobacteria: The Role Of Light And Bicarbonate

Mass Culture of High Oil Content Microalgae on Wastewater and Power Plant Flue Gases

Novel Regeneration and Utilization Concept Using Rich Chemical Absorption Solvent As a Carbon Source for Microalgae Biomass Production