Abstract:This paper describes a highly-integrated CMOS system-on-chip (SoC) for active structural health monitoring (SHM). The chip integrates ultrasonic power and bidirectional half-duplex data transfer, a power management unit (PMU), and an ultrasound transceiver to enable wireless ultrasonically-coupled sensor SHM networks on structures. The PMU includes an active bias-flip rectifier with off-delay compensation, a high-efficiency dual-path DC-DC converter with inductor time-sharing, and five switched-capacitor DC-DC converters to generate multi-level spectrally band-limited pulses for guided-wave SHM. The chip was fabricated in a standard 180 nm process and has a die area of mm2. Test results show power conversion efficiency (PCE) > 85% for the active rectifier, > 70% for the inductive DC-DC converter, and > 60% for the switched-capacitor DC-DC converters. Output pulses have a peak-to-sidelobe ratio (PSL) > 30 dB and worst-case out-of-band emissions < −30 dB, respectively. The SoC was integrated with a low-power microcontroller and passive components to realize miniaturized (15 mm mm) wireless SHM nodes. A set of nodes was deployed on an SHM test-bed (carbon fiber reinforced polymer sheet) representing an airframe panel. Tests on this wireless network confirm both long-range ultrasound power/data transfer and the ability to detect structural damage.

Dedicated ICs for Wearable Body Sound Monitoring.

A Wireless Body Sound Sensor with a Dedicated Compact Chipset

A receiver analog front-end for body sensor network

A Multi-Parameter Bio-Electric ASIC Sensor with Integrated 2-Wire Data Transmission Protocol for Wearable Healthcare System

Body Heat Powered Wirelessly Wearable System for Real‐time Physiological and Biochemical Monitoring

Design of a self-organized Intelligent Electrode for synchronous measurement of multiple bio-signals in a wearable healthcare monitoring system

A Fully Integrated Wireless SoC for In-Body Ph and Temperature Continuous Monitoring

A 74-μW 11-Mb/s Wireless Vital Signs Monitoring SoC for Three-Lead ECG, Respiration Rate, and Body Temperature

A 769 Μw Battery-Powered Single-Chip SoC with BLE for Multi-Modal Vital Sign Monitoring Health Patches.

Low Power Ic Design of the Wireless Monitoring System of the Orthopedic Implants

A Novel Low-Power Compact WBS Human Body Channel Receiver for Wearable Vital Signal Sensing Application in Wireless Body-Area Network

Wireless Sensing System-on-Chip for Near-Field Monitoring of Analog and Switch Quantities

An Energy Efficient Fully Integrated OOK Transceiver SoC for Wireless Body Area Networks

A CMOS SoC for Wireless Ultrasonic Power/Data Transfer and SHM Measurements on Structures

A 0.66mw 400 MHz/900 MHz Transmitter IC for In-Body Bio-Sensing Applications.

An ECG-on-Chip for Wearable Cardiac Monitoring Devices

A near-threshold, multi-node, wireless body area sensor network powered by RF energy harvesting

A CMOS Physiological Monitoring Frontend for Wearable Health Applications

High-Sensitivity Software-Configurable 5.8-Ghz Radar Sensor Receiver Chip In 0.13-Mu M Cmos For Noncontact Vital Sign Detection

22.1 A 769μw Battery-Powered Single-Chip SoC with BLE for Multi-Modal Vital Sign Health Patches

Monitoring of physiological sounds with wearable device based on piezoelectric MEMS acoustic sensor