Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Interactions of Liquid Oxygen Droplet Vaporization in High Pressure Hydrogen Environment

Vaporization of two liquid oxygen (LOX) droplets in tandem in convective hydrogen streams at supercritical pressures

Vaporization of Liquid Oxygen (lox) Droplets in Hydrogen and Water Environments under Sub- and Super-Critical Conditions

Pressure-Coupled Responses of LOX Droplet Vaporization and Combustion in High-Pressure Hydrogen Environments

Clustering effects on liquid oxygen (LOX) droplet vaporization in hydrogen environments at subcritical and supercritical pressures

Transport and Dynamics of Liquid Oxygen Droplets in Supercritical Hydrogen Streams

Exploration of Shock–droplet Interaction Based on High-Fidelity Simulation and Improved Theoretical Model

Supercritical Vaporization of Two Droplets in Tandem in Convective Environments

Measurement of Interacting Ethanol Droplets Evaporation at Moderately Elevated Temperature and Pressure Using Phase Rainbow Refractometry

Pressure-coupled vaporization response of n-pentane fuel droplet at subcritical and supercritical conditions

Apparatus to investigate liquid oxygen droplet combustion in hydrogen under microgravity conditions

Droplet Evaporation to Boiling in Van Der Waals Fluid

The Interaction Between Droplet Evaporation and Turbulence with Interface-Resolved Direct Numerical Simulation

Vaporization dynamics of a super-heated water-in-oil droplet: modeling and numerical solution

Theoretical Investigation of the Influence of Liquid Physical Properties on Effervescent Atomization Performance

Atmospheric pressure plasma jet interacting with a droplet on dielectric surface

Theoretical analysis on droplet vaporization at elevated temperatures and pressures

Turbulence, Evaporation and Combustion Interactions in N-Heptane Droplets under High Pressure Conditions Using DNS

Interactive vaporization and combustion of binary droplet systems

Numerical Analysis of Liquid Hydrogen Atomization in a Premixing Tube Using a Volume of Fluid-to-Discrete Particle Model Approach

Two-phase Interactions between Propagating Shock Waves and Evaporating Water Droplets