Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Vaporization of Liquid Oxygen (lox) Droplets in Hydrogen and Water Environments under Sub- and Super-Critical Conditions

Vaporization of two liquid oxygen (LOX) droplets in tandem in convective hydrogen streams at supercritical pressures

Transport and Dynamics of Liquid Oxygen Droplets in Supercritical Hydrogen Streams

Pressure-Coupled Responses of LOX Droplet Vaporization and Combustion in High-Pressure Hydrogen Environments

Interactions of Liquid Oxygen Droplet Vaporization in High Pressure Hydrogen Environment

Clustering effects on liquid oxygen (LOX) droplet vaporization in hydrogen environments at subcritical and supercritical pressures

Modeling Droplet Vaporization and Combustion with the Volume of Fluid Method at a Small Reynolds Number

Vaporization dynamics of a super-heated water-in-oil droplet: modeling and numerical solution

Droplet Evaporation to Boiling in Van Der Waals Fluid

Pressure-coupled vaporization response of n-pentane fuel droplet at subcritical and supercritical conditions

Numerical Simulation for Combustion of Droplet with Volume of Fluid Formulation

Supercritical Vaporization of Two Droplets in Tandem in Convective Environments

Experimental study on the direct contact condensation of gaseous oxygen jets in crossflow of liquid oxygen

Evaporation and Combustion Characteristics of Hydrocarbon Fuel Droplet in Sub- and Super-Critical Environments

Evaporation and combustion characteristics for a droplet of lubricating oil and gasoline

A Study on Flow and Heat Transfer Characteristics for Saturated Falling-Film Evaporation of Liquid Oxygen in a Vertical Channel

Theoretical analysis on droplet vaporization at elevated temperatures and pressures

Interface-resolved simulation of the evaporation and combustion of a fuel droplet suspended in normal gravity

Analysis of Evaporation and Autoignition of Droplet Clouds with a Unit Cell Model Considering Transient Evaporating Boundary Layer

Internal Boiling and Superheating in Vaporizing Multicomponent Droplets

Numerical study of the pseudo-boiling phenomenon in the transcritical liquid oxygen/gaseous hydrogen flame