Abstract:For make full rational use of the packed media surface, the fluent software was used to the section area of the bio-trickling filter's inlet is enlarged and the outlet gradually converged. The enlarged cross-flow bio-trickling filter is characterized with low pressure drop and uniform distribution of gas and spray liquid. The filter inoculated with efficient Pseudomonas putida on the ceramic pellets was developed to degrade toluene. With inlet concentration ranging from 342 mg/m(3) to 690 mg/m(3), at the residence time of 140 s and the temperature ranging from 13.5 degrees C to 29.6 degrees C 8days were needed to start the filter and the removal efficiency of toluene was up to 85 %. The effects of nutrient N, P content was studied, which showed that the improved type of MS culture medium ( N: P = 5: 1) of the microbial biofilm play an important role in promoting biofilm forming. In the stable operation stage, the temperature ranging from 16.5 degrees C to 35.7 degrees C when the residence time is 47 s, the removal efficiency fluctuates with the inlet concentration increases during 40 days. When the inlet concentration is lower than 650 mg/m(3), removal efficiency is higher than 95 %, and with the inlet concentration increases to 1000 mg/m(3), the removal efficiency decreases to 84 %. But the efficiency increases in a short time and residences in a high level. When the residence time is for 140 s, 93 s, 70 s, 56 s, 47 s, 40 s, 35 s and 32s respectively, and the inlet toluene concentration is about 500 mg/m(3), the average removal efficiency is 100 %, 99.5 %, 99.2 %, 96.2 %, 94.1 %, 91.8 %, 91.6 % and 88.8 % respectively. Contamination and circulation fluid bed filter in the cross- flow operation, circulating fluid pH value of 7.0 similar to 8.0, the biofilm system can better adapt to the changes of inlet toluene concentration.

Performance of a Suspended Biofilter As a New Bioreactor for Removal of Toluene

Removal of Toluene from Air Streams Using A Gas-Liquid-Solid Three-Phase Airlift Loop Bioreactor Containing Immobilized Cells

Tubular biofilter for toluene removal under various organic loading rates and gas empty bed residence times.

[Biological Removal of VOCs Emissions].

Removal of Toluene Waste Gas by a Cross-flow Trickling Biofilter

Performance and Bacterial Diversity of Biotrickling Filters Filled with Conductive Packing Material for the Treatment of Toluene

A Comparative Study of Bacterial and Fungal‐bacterial Steady‐state Stages of a Biofilter in Gaseous Toluene Removal: Performance and Microbial Community

An approach to purification of toluene waste gas by a cross-flow bio-trickling filter

Study on Gaseous Chlorobenzene Treatment by a Bio-Trickling Filter: Degradation Mechanism and Microbial Community

[Removal of Toluene Waste Gas by Pseudomonas Putida with a Bio-Trickling Filter].

Study of the Performance of Biotrickling Filter for Removing Toluene Waste Gas

Rapid start-up processes of a high performance biotrickling filter

Screening and Study of the Degradation Characteristics of Efficient Toluene Degrading Bacteria Combinations

Start-Up Processes Of A Cross-Flow Trickling Biofilter Removing Toluene

Purifying of toluene using biofilter packed with complex organic filler

Biodegradation of gaseous toluene with mixed microbial consortium in a biofilter: steady state and transient operation

Mesophilic and thermophilic biofiltration of gaseous toluene in a long-term operation: performance evaluation, biomass accumulation, mass balance analysis and isolation identification.

Effect of Toluene on M-Xylene Removal in a Biotrickling Filter: Performance, Biofilm Characteristics, and Microbial Analysis.

Numerical Simulation for Volatile Organic Compound Removal in Rotating Drum Biofilter

Performance of an Intermittently Loaded Bio-trickling Filter for Treating Organic Waste Vapors from Printing and Coating Facilities

Purification of Low Concentration Toluene Waste Gas by an Enlarged Cross-Flow Bio-Trickling Filter